Poulan HDF550 Support and Manuals
Get Help and Manuals for this Poulan item
This item is in your list!
View All Support Options Below
Free Poulan HDF550 manuals!
Problems with Poulan HDF550?
Ask a Question
Free Poulan HDF550 manuals!
Problems with Poulan HDF550?
Ask a Question
Popular Poulan HDF550 Manual Pages
User Manual - Page 1
IMPORTANT MANUAL
Do Not Throw Away
OPERATOR'S MANUAL
MODEL:
HDF550
FRONT TINE TILLER
WARNING:
Read this Manual and follow all Warnings and Safety Instructions.
Failure to do so can result in U.S.A. ALWAYS WEAR EYE PROTECTION DURING OPERATION Visit our website: www.poulan.com • Español, p. 18
194793 Rev. 1 12.05.04 TR Printed in serious injury.
User Manual - Page 2
... refer to the operator's guide instructions for important details if the tiller is highly flammable.
• Use an approved fuel container.
• Never add fuel to prevent accidental starting when setting up spilled fuel before starting .Disconnect the cord on slippery
surfaces. Never fill fuel tank indoors.
• Replace gasoline cap securely and...
User Manual - Page 3
The instructions will enable you to assemble and maintain your nearest authorized service center.
IN THE STATE OF CALIFORNIA, A SPARK ARRESTER IS REQUIRED BY LAW (SECTION 4442 OF THE CALIFORNIA PUBLIC RESOURCES CODE). FEDERAL LAWS APPLY ON FEDERAL LANDS. It has been designed, engineered and manufactured to service or repair this manual. Please read and retain this...
User Manual - Page 4
... and proper operation of those parts left hand is mentioned in the operating position (standing behind tiller handles). TOOLS REQUIRED FOR ASSEMBLY
A socket wrench set will make assembly easier. ASSEMBLY
Your new tiller has been assembled at the factory with exception of your tiller all parts and hardware you are in this manual, it means when you...
User Manual - Page 5
... your tilling conditions (See "TINE ARRANGEMENT" in the Service and Adjustments section of this manual). Repeat for opposite side. If it does not, loosen support bolt. TILLING WIDTH
•... 5/16-18X3/4"
02051
CABLE(S)
TILLER HANDLES
HANDLE PANEL BOLTS
INSTALL DEPTH STAKE ASSEMBLY (See Fig. 3)
• Loosen nut "A".
• Insert stake support between engine bracket halves with handle...
User Manual - Page 8
... spark plug wire is held by the stake
spring. • Push tiller handles down, raising tines off any source of this manual). CAUTION: Alcohol blended fuels (called gasohol or using ethanol or methanol)... gas can be emptied before
valve life). To avoid engine problems, the fuel system should change engine oil, see "PRODUCT SPECIFICATIONS" on its wheels and then re-level.
• With...
User Manual - Page 9
... and slowing your tiller, start , see troubleshooting points. See"TINE OPERATION CHECK" in the soil being tilled.The proper setting of this .
If you are not set properly in the Service and Adjustments section of the wheels and depth stake is shaking, the wheels and depth stake are straining or tiller is through trial and error and depends...
User Manual - Page 10
... warranty, the operator must maintain tiller as instructed in dirty or dusty conditions. Some adjustments will need to be made periodically to properly maintain your engine run better and last longer.
LUBRICATION
Keep unit well lubricated (See "LUBRICATION CHART"). SERVICE DATES
GENERAL RECOMMENDATIONS
The warranty on this manual. Service more often when operating under a heavy...
User Manual - Page 12
...
• Tighten the four nuts securely. SERVICE AND ADJUSTMENTS
CAUTION: Disconnect spark plug wire ...tine hubs to holes "C" in several different ways to suit your tiller when the engine and transmission are covered to holes "B" in "PRODUCT SPECIFICATIONS...manual. TILLER
TO ADJUST HANDLE HEIGHT (See Fig. 15)
Factory assembly has provided lowest handle height. Inspect periodically and replace...
User Manual - Page 13
... the ground.
• Slowly pull recoil starter handle while observing tines.
There are mounted to raise tines off the ground.
• Slowly pull recoil starter handle while observing tines. Tines should rotate forward.
• If tines do not remove) tine shield nut on end of manual. SERVICE AND ADJUSTMENTS
NARROW TILLING/CULTIVATING - 12-3/4" PATH (See Fig. 18) •...
User Manual - Page 14
... by differences in this section of
manual. However, engine performance can be necessary. OVERSPEEDING THE ENGINE ABOVE THE FACTORY HIGH SPEED SETTING CAN BE DANGEROUS. CHECK TINE OPERATION • See "TINE OPERATION CHECK" in fuel, temperature, altitude or load.
SERVICE AND ADJUSTMENTS
FORWARD MOTION (INSIDE) V-BELT
ENGINE PULLEY BELT GUIDE
TRANSMISSION PULLEY
REVERSE IDLER PULLEY...
User Manual - Page 15
...See "ENGINE" in your gasoline will cause problems. • If possible, store your unit ... manual.
• Be sure that
does not retain moisture. Inspect moving parts ...TILLER
• Clean entire tiller (See "CLEANING" in the Maintenance section of this manual).
• Inspect and replace belts, if necessary (See belt replacement instructions in the Service and Adjustments section of this manual...
User Manual - Page 16
TROUBLESHOOTING POINTS
PROBLEM Will not start . 4. Out of adjustment. 13. Engine not "CHOKED" properly. 3.
Clean or replace air cleaner cartridge. 5. Make sure spark plug wire is seated properly on
plug. 6. Throttle control not set... 2. Clogged fuel tank. 7. Replace spark plug or adjust gap.... service center...Set depth stake and ...tine control. 2.
Set.... 2. Tine control is...
User Manual - Page 17
... incurred in replacing parts, any power equipment unit or attachment are belts, tines, tine adapters, normal wear, normal adjustments, standard hardware and normal maintenance.
6. Should you have any products used for any unanswered questions concerning this Warranty, you have been properly assembled, adjusted, operated, and maintained in accordance with the instructions furnished. The...
User Manual - Page 36
...:
a. Model Number/Manufacturer's I.D. PARTS AND SERVICE
This product has been expertly engineered and carefully manufactured to continually improve all of its authorized distributors and dealers; As with all requests for updated information and assistance. therefore, all mechanical products, some adjustments or part replacement may be directed to our website: www.poulan.com/support.asp...
Poulan HDF550 Reviews
Do you have an experience with the Poulan HDF550 that you would like to share?
Earn 750 points for your review!
We have not received any reviews for Poulan yet.
Earn 750 points for your review!