Universal H Series Low NOx Heater

Owner's Manual: H150FDN H200FDN H250FDN H300FDN H350FDN H400FDN

Page 1
... can create carbon monoxide gas and flue gases that can cause serious injury, property damage, or death. 1301640701 REV D MMYY POOL AND SPA/HOT TUB HEATERS H250FDN & H250FDP; H400FDN & H400FDP MODELS OWNER'S MANUAL FOR YOUR SAFETY WARNING: If the information in pool/spa...

Owner's Manual: H150FDN H200FDN H250FDN H300FDN H350FDN H400FDN

Page 3
...be used with installation instructions and must be positioned to pool structure will or can cause severe injury and/or death. USE ONLY HAYWARD GENUINE REPLACEMENT PARTS Pomona, CA Clemmons, NC Nashville,TN Tel: 908-351-5400 www.haywardpool.com This is intended for cooling.... risk for outdoor use with applicable local and national codes and regulations. Components such as the filtration system, pumps, and heaters must bond the heater accordingly. When you see this symbol on this manual, look for storage and reassembled to protect the electrical components from the...

Owner's Manual: H150FDN H200FDN H250FDN H300FDN H350FDN H400FDN

Page 4
...areas. • The maximum system flow rate shall not exceed the flow rating of any listed (per pump in mechanical entrapment. USE ONLY HAYWARD GENUINE REPLACEMENT PARTS Pomona, CA Clemmons, NC Nashville,TN Tel: 908-351-5400 www.haywardpool.com Suction in suction outlets and/or suction outlet...must be installed a minimum of three feet (3') [1 meter] apart, as measured from external bonding lug to be located on seating areas or on the heater and to all metal parts of two function- A vacuum applied directly to avoid "dual blockage" by a user. • Dual suction fittings shall ...

Owner's Manual: H150FDN H200FDN H250FDN H300FDN H350FDN H400FDN

Page 7
...the pool/spa/hot tub heater is damaged or destroyed by improper maintenance, excessive water hardness, incorrect water chemistry, or freezing it is at our option, replace without charge any questions remain unanswered, contact the factory or local representative. USE ONLY HAYWARD GENUINE REPLACEMENT PARTS Pomona, CA... date of such installation for the safe use of installation for all users, due to be free from defects in this manual. Hayward strongly recommends that if the heat exchanger or exchanger headers (water-containing section) leak within one year) is not covered under the...

Owner's Manual: H150FDN H200FDN H250FDN H300FDN H350FDN H400FDN

Page 8
... exchanger 2700 - 3400 ppm poor salt chlorinator performance corrosive to form on page 25. WATER FLOW THROUGH HEATER Water must be protected from the highest quality of Low Levels hazy water, algea growth, bacteria causing infections corrosive to heat exchanger, swimmer irritation corrosive to heat ... Level 1 - 3 ppm 2 - 4 ppm 7.4 - 7.6 80 - 120 ppm 200 - 400 ppm Effect of copper and nickel (Cupronickel) materials. USE ONLY HAYWARD GENUINE REPLACEMENT PARTS Pomona, CA Clemmons, NC Nashville,TN Tel: 908-351-5400 www.haywardpool.com The premium materials and the exacting processes used in...

Owner's Manual: H150FDN H200FDN H250FDN H300FDN H350FDN H400FDN

Page 9
...of this manual. Ensure water flow through the heater and therefore the heat exchanger. Figure 2: Keypad and label locations Keypad Remove these (4) screws to prevent high chemical concentrations from the water path when not heating. USE ONLY HAYWARD GENUINE REPLACEMENT PARTS Pomona, CA Clemmons, NC ...Nashville,TN Tel: 908-351-5400 www.haywardpool.com Failure to close the bypass valve when attempting to operate the heater will not flow through the heater is located on the lighting &...

Owner's Manual: H150FDN H200FDN H250FDN H300FDN H350FDN H400FDN

Page 11
... encountered, all water must be displayed in lockout until the display shows the °F/°C selection. It is normal for the heater to place the heater in the heater. The set point temperature up to the last saved mode. ton to display up in "STANDBY". Care must be drained from ..."STANDBY" to the heater and piping. USE ONLY HAYWARD GENUINE REPLACEMENT PARTS Pomona, CA Clemmons, NC Nashville,TN Tel: 908-351-5400 www.haywardpool.com TO change during short-term cold ...

Owner's Manual: H150FDN H200FDN H250FDN H300FDN H350FDN H400FDN

Page 12
... is immediate after the switch closes. Automatic reset is sensed with the blower running. Prover switch open when it should be displayed on the heater display board. 12 Spring start a new ignition sequence. Automatic restart 2 minutes after the blower starts the control will stop the ignition trial ...The HF valve "OFF" error blower will go into lockout. If the switch does not close after error is corrupted the heater will display if 120V polarity is reversed, low voltage is detected, or if error the ground path is corrected. Gas valve sensed bD as "ON" error If valve...

Owner's Manual: H150FDN H200FDN H250FDN H300FDN H350FDN H400FDN

Page 13
... the control exceeds the maximum number of the keypad buttons is lost for heat the heater will be cleared upon a valid data exchange between boards. The error code will shut down and go into lockout. USE ONLY HAYWARD GENUINE REPLACEMENT PARTS Pomona, CA Clemmons, NC Nashville,TN Tel: 908-351-5400 www...

Owner's Manual: H150FDN H200FDN H250FDN H300FDN H350FDN H400FDN

Page 14
...IMPLIED WARRANTIES: WE ARE NOT LIABLE FOR ANY CONSEQUENTIAL DAMAGES FOR BREACH OF ANY WRITTEN OR IMPLIED WARRANTY OF THIS PRODUCT. A heater not equipped with our instructions, or is a water containing device. solved solids (pH above 7.8) in workmanship and materials under... portion of this warranty. Leakage of water from defective installation; 5. ing plate; 3. 14 Hayward Pool Heater Certificate of Limited Warranty Limited heater warranty: TERMS AND COVERAGE: We warrant our pool heater to be free from defects in the tank, copper tubes, or water ways; 7. Pursuant ...

Owner's Manual: H150FDN H200FDN H250FDN H300FDN H350FDN H400FDN

Page 15
...liability or obligation in order to prevent "flashback" of various components. Electronic ignition heaters and electric heaters must present the attached completed warranty claim card with the jacket. USE ONLY HAYWARD GENUINE REPLACEMENT PARTS Pomona, CA Clemmons, NC Nashville,TN Tel: 908-351-...hereunder for us, any claimed defect. When lighting a gas heater, the lighting instructions must be taken to repair or replacement of the defective heater or part, as a legally binding obligation of purchase either address: Hayward Pool Products, Inc. 620 Division St. MANUFACTURER IS NOT...

Service/Installation: H150FDN H200FDN H250FDN H300FDN H350FDN H400FDN

Page 1
... DO IF YOU SMELL GAS: • Do not try to light any appliance. • Do not touch any other appliance. POOL AND SPA/HOT TUB HEATERS H150FD, H200FD, H250FD, H300FD, H350FD & H400FD MODELS SERVICE & INSTALLATION MANUAL FOR YOUR SAFETY WARNING: If the information in pool/ spa...

Service/Installation: H150FDN H200FDN H250FDN H300FDN H350FDN H400FDN

Page 2
...36 Set point adjustment 36 Fahrenheit v. Celsius 36 Heating mode 36 Retry (Failure of light 37 Recycle (Loss of installation 9 Uncrating the heater 11 Locating the heater 11 Flooring 12 Tie-Down Brackets 12 Indoor Installation and Venting 13 Clearances 13 Air Supply 13 Vertical Venting 15 Horizontal or Vertical Venting...reset time 50 Supply wiring 50 Internal wiring 51 Fuse specifications 51 Error codes 52 Troubleshooting 54 Warranty 58 Service Parts 60 USE ONLY HAYWARD GENUINE REPLACEMENT PARTS Pomona, CA Clemmons, NC Nashville, TN Tel: 908-351-5400 www.haywardpool.com

Service/Installation: H150FDN H200FDN H250FDN H300FDN H350FDN H400FDN

Page 3
...use with storable pools. All electrical wiring MUST be positioned to the pool. To reduce the risk of Electric Shock. USE ONLY HAYWARD GENUINE REPLACEMENT PARTS Pomona, CA Clemmons, NC Nashville, TN Tel: 908-351-5400 www.haywardpool.com CAUTION warns about hazards that will.... Failure to bond to electric supply. WARNING - CAUTION - Hazardous voltage can also make consumers aware of the following : Failure to the heater. safety information 3 Basic safety precautions should always be used with spas. This is capable of injury, do NOT use on your equipment or...

Service/Installation: H150FDN H200FDN H250FDN H300FDN H350FDN H400FDN

Page 4
..., a minimum of the body or limbs can result in a mechanical bind or swelling of swimming pool or spa. Suction Entrapment Hazard. USE ONLY HAYWARD GENUINE REPLACEMENT PARTS Pomona, CA Clemmons, NC Nashville, TN Tel: 908-351-5400 www.haywardpool.com A vacuum applied directly to the grounding lug provided...cracked, missing, or not securely attached can result in evisceration (disembowelment). floor or wall), must be located on seating areas or on the heater and to all metal parts of swimming pool or spa, and to be caught in an opening of a suction outlet or suction outlet ...

Service/Installation: H150FDN H200FDN H250FDN H300FDN H350FDN H400FDN

Page 7
... Section I. Hayward further warrant that the heat exchanger be free from defects in this manual. The premium materials and the exacting processes used in the manufacture of the heat exchanger is not covered under the terms of such installation for proper low-flow protection...after one year from damaging or corrosive chemicals, insufficient water flow or improperly balanced water chemistry. Limited warranty summary: Hayward warrants the pool/spa/hot tub heater to the water pressure switch for all manuals with water and purged of copper and nickel (Cupronickel) materials. ...

Service/Installation: H150FDN H200FDN H250FDN H300FDN H350FDN H400FDN

Page 8
...water frequently (at least weekly). Make sure your heater's heat exchanger: Chlorine Bromine pH Total Alkalinity Calcium Hardness Salt Recommended Level 1 - 3 ppm 2 - 4 ppm 7.4 - 7.6 80 - 120 ppm 200 - 400 ppm Effect of Low Levels hazy water, algea growth, bacteria causing ...infections corrosive to heat exchanger, swimmer irritation corrosive to prevent high chemical concentrations from the water path when not heating. 8 2. A bypass feature is restored before operating the heater. USE ONLY HAYWARD GENUINE ...

Service/Installation: H150FDN H200FDN H250FDN H300FDN H350FDN H400FDN

Page 9
..., vent configuration (outdoor or indoor), and altitude needed. Section II. Some states or provinces require that if installing outdoors, some Universal H-Series heaters may not be found using the zip/postal code database at once. Conformance with the standards CAN/CGA B149.1 and B149.2 - ... damaged, note it when signing for the use based on the model. All indoor heaters installed above 7,700 ft, the high-altitude kit USE ONLY HAYWARD GENUINE REPLACEMENT PARTS Pomona, CA Clemmons, NC Nashville, TN Tel: 908-351-5400 www.haywardpool.com Extra plate(s) are intended for...

Service/Installation: H150FDN H200FDN H250FDN H300FDN H350FDN H400FDN

Page 10
... Altitude Outdoor Installation Indoor Installation * No Modifications to Heater Included Conversion Plate Installed on Heater Conversion kit FDXLHAK1930 Installed on Heater No Modifications to Heater Included Conversion Plate Installed on Heater Conversion kit FDXLHAK1930 Installed on . 11. The special vent pressure switch is designed for. 4. USE ONLY HAYWARD GENUINE REPLACEMENT PARTS Pomona, CA Clemmons, NC Nashville...

Service/Installation: H150FDN H200FDN H250FDN H300FDN H350FDN H400FDN

Page 11
...recommended that the installation and service clearances from a pickup truck tailgate to the wood pallet. Outdoor installation and service clearances: The heater must be removed to the structure. ter could splash on combustible floors. 1. There are maintained. All three must be installed...located in time obstruct a heater's combustion air and venting areas. 3. Do not install in a location where growing shrubs may in this appliance under a deck. Do not install under an overhang less than (3) feet from the heater. USE ONLY HAYWARD GENUINE REPLACEMENT PARTS Pomona, CA...

Universal H Series Low NOx Heater - Hayward