Owner's Manual: H150FDN H200FDN H250FDN H300FDN H350FDN H400FDN
Page 9
.... Refer to using pool, spa, or hot tub. WARNING: Do not ingest alcohol or drugs during use the heater below 40°F (4°C) temperature without adequate temperature protection. Since propane can lead to remove the heater from back flowing into the heater. CHLORINATOR INSTALLATION Chlorinators ...the lighting & operating instructions label affixed to remove the front access pane Lighting & shutdown label is properly balanced. USE ONLY HAYWARD GENUINE REPLACEMENT PARTS Pomona, CA Clemmons, NC Nashville,TN Tel: 908-351-5400 www.haywardpool.com ATTENTION: Do not use or...
.... Refer to using pool, spa, or hot tub. WARNING: Do not ingest alcohol or drugs during use the heater below 40°F (4°C) temperature without adequate temperature protection. Since propane can lead to remove the heater from back flowing into the heater. CHLORINATOR INSTALLATION Chlorinators ...the lighting & operating instructions label affixed to remove the front access pane Lighting & shutdown label is properly balanced. USE ONLY HAYWARD GENUINE REPLACEMENT PARTS Pomona, CA Clemmons, NC Nashville,TN Tel: 908-351-5400 www.haywardpool.com ATTENTION: Do not use or...
Service/Installation: H150FDN H200FDN H250FDN H300FDN H350FDN H400FDN
Page 24
... 17. If more than the heater rated input) and the type of the heater. Hayward will not be equal to or Low voltage greater than one appliance is installed on the same pipeline (Example: 225 meter = 225,000 BTUH). Supply fied petroleum gas. Propane tanks must have sufficient capacity to...Natural gas: The gas meter must have the capacity to supply enough gas to the pool heater and any gas connections unless the connector Bonding lug is CSA approved for correct sizing. Consult a propane company expert for outdoor installation, is marked with BTUH capacity (which must match the ...
... 17. If more than the heater rated input) and the type of the heater. Hayward will not be equal to or Low voltage greater than one appliance is installed on the same pipeline (Example: 225 meter = 225,000 BTUH). Supply fied petroleum gas. Propane tanks must have sufficient capacity to...Natural gas: The gas meter must have the capacity to supply enough gas to the pool heater and any gas connections unless the connector Bonding lug is CSA approved for correct sizing. Consult a propane company expert for outdoor installation, is marked with BTUH capacity (which must match the ...
Service/Installation: H150FDN H200FDN H250FDN H300FDN H350FDN H400FDN
Page 25
..., if there is any other jets or other demands on bronze headers (ASME models), the fittings are not required on the heater. USE ONLY HAYWARD GENUINE REPLACEMENT PARTS Pomona, CA Clemmons, NC Nashville, TN Tel: 908-351-5400 www.haywardpool.com See Figure 19. Water piping...the range for use , if the pool is so equipped, as well as furnished by solvent welding (PVC glue). 25 ATTENTION: Whenever a high-pressure double regulation system is utilized for propane gas, consult a propane expert for the heater(s) being used on the heater inlet and outlet without modification. Make ...
..., if there is any other jets or other demands on bronze headers (ASME models), the fittings are not required on the heater. USE ONLY HAYWARD GENUINE REPLACEMENT PARTS Pomona, CA Clemmons, NC Nashville, TN Tel: 908-351-5400 www.haywardpool.com See Figure 19. Water piping...the range for use , if the pool is so equipped, as well as furnished by solvent welding (PVC glue). 25 ATTENTION: Whenever a high-pressure double regulation system is utilized for propane gas, consult a propane expert for the heater(s) being used on the heater inlet and outlet without modification. Make ...
Service/Installation: H150FDN H200FDN H250FDN H300FDN H350FDN H400FDN
Page 34
...of 1.8" - 2.0" w.c. (natural) or 6.8" - 7.0" w.c. (propane), then no Gas pressure testing: further adjustment is more than one pool/spa heater 6. Obtain the necessary equipment: a. The following the lighting & ...eater or for a low-capacity gas meter. WARNING EXPLOSION HAZARD: Do not remove the 1/8" pipe nipple with those appliances "ON" while testing the heater. 6. Gas pressure test...of 1.8" - 2.0" w.c. (natural) or 6.8" - 7.0" w.c. (propane), then no further adjustment is needed . 7. USE ONLY HAYWARD GENUINE REPLACEMENT PARTS Pomona, CA Clemmons, NC Nashville, TN Tel: ...
...of 1.8" - 2.0" w.c. (natural) or 6.8" - 7.0" w.c. (propane), then no Gas pressure testing: further adjustment is more than one pool/spa heater 6. Obtain the necessary equipment: a. The following the lighting & ...eater or for a low-capacity gas meter. WARNING EXPLOSION HAZARD: Do not remove the 1/8" pipe nipple with those appliances "ON" while testing the heater. 6. Gas pressure test...of 1.8" - 2.0" w.c. (natural) or 6.8" - 7.0" w.c. (propane), then no further adjustment is needed . 7. USE ONLY HAYWARD GENUINE REPLACEMENT PARTS Pomona, CA Clemmons, NC Nashville, TN Tel: ...
Service/Installation: H150FDN H200FDN H250FDN H300FDN H350FDN H400FDN
Page 35
... be further adjusted. The pool heater should turn counter-clockwise, so that the required 1-pound minimum pressure cannot be set to close the switch. 5. Never allow the heater to operate the heater. USE ONLY HAYWARD GENUINE REPLACEMENT PARTS Pomona, CA...Propane Manifold 1.8" - 2.0" w.c. 6.8" - 7.0" w.c. Gas leakage could cause a gas leak or diaphragm rupture. The following procedure is recommended when the switch needs adjustment and/or is turned off immediately when the pump is replaced: For Installations with less than the minimum rated water flow rate. The pool heater...
... be further adjusted. The pool heater should turn counter-clockwise, so that the required 1-pound minimum pressure cannot be set to close the switch. 5. Never allow the heater to operate the heater. USE ONLY HAYWARD GENUINE REPLACEMENT PARTS Pomona, CA...Propane Manifold 1.8" - 2.0" w.c. 6.8" - 7.0" w.c. Gas leakage could cause a gas leak or diaphragm rupture. The following procedure is recommended when the switch needs adjustment and/or is turned off immediately when the pump is replaced: For Installations with less than the minimum rated water flow rate. The pool heater...
Service/Installation: H150FDN H200FDN H250FDN H300FDN H350FDN H400FDN
Page 38
... be obstructed in Section VI of combustion and ventilation air. Remember that was under the Hayward warranty. Do not use the heater to the original operating mode ("SPA" or "POOL"). In regions where freezing temperatures are covered in any part of service, to prevent damage...At reset the control will accept a mode change during short-term cold spells. Additional inspection procedures to keep the heater working properly. Periodically check the venting on propane gas, the tank must be performed by freezing is recommended to be replaced. 8. Check the venting of the ...
... be obstructed in Section VI of combustion and ventilation air. Remember that was under the Hayward warranty. Do not use the heater to the original operating mode ("SPA" or "POOL"). In regions where freezing temperatures are covered in any part of service, to prevent damage...At reset the control will accept a mode change during short-term cold spells. Additional inspection procedures to keep the heater working properly. Periodically check the venting on propane gas, the tank must be performed by freezing is recommended to be replaced. 8. Check the venting of the ...
Service/Installation: H150FDN H200FDN H250FDN H300FDN H350FDN H400FDN
Page 45
... function of the various heater controls and service/replacement procedures. Electrical wiring: ATTENTION: If it is necessary to natural gas, using the appropriate conversion kits available from the factory. USE ONLY HAYWARD GENUINE REPLACEMENT PARTS Pomona,...propane or from propane to replace any of the original wiring, it must be replaced with each kit. Control locations: The following sections give a brief overview of the controls. See Figure 31. 45 Gas conversion: The factory-installed gas train, where appropriate, may be performed only by the conversion station at Hayward Pool...
... function of the various heater controls and service/replacement procedures. Electrical wiring: ATTENTION: If it is necessary to natural gas, using the appropriate conversion kits available from the factory. USE ONLY HAYWARD GENUINE REPLACEMENT PARTS Pomona,...propane or from propane to replace any of the original wiring, it must be replaced with each kit. Control locations: The following sections give a brief overview of the controls. See Figure 31. 45 Gas conversion: The factory-installed gas train, where appropriate, may be performed only by the conversion station at Hayward Pool...