Warranty, Maitenance, Services Guide
Page 25
... the engine oil at specified intervals. Tighten connections or replace parts as necessary. Explanation of the drive shaft bolt for proper torque. Fuel Lines and Connections, Fuel Tank Band and Fuel Tank Vapor Vent System Hoses Visually inspect for excessive lifter noise and engine vibration and adjust if necessary. Engine Coolant Drain and flush the...
... the engine oil at specified intervals. Tighten connections or replace parts as necessary. Explanation of the drive shaft bolt for proper torque. Fuel Lines and Connections, Fuel Tank Band and Fuel Tank Vapor Vent System Hoses Visually inspect for excessive lifter noise and engine vibration and adjust if necessary. Engine Coolant Drain and flush the...
Warranty, Maitenance, Services Guide
Page 26
... joint with molybdenum-disulfide lithium-base chassis grease. Only a qualified technician should perform these operations. 22 General Maintenance Information Install new plugs of Maintenance Items Fuel Tank Cap Gasket Visually inspect for signs of leakage. Steering Linkage and Boots With the vehicle stopped, check for deterioration, cracks and damage. A qualified technician should...
... joint with molybdenum-disulfide lithium-base chassis grease. Only a qualified technician should perform these operations. 22 General Maintenance Information Install new plugs of Maintenance Items Fuel Tank Cap Gasket Visually inspect for signs of leakage. Steering Linkage and Boots With the vehicle stopped, check for deterioration, cracks and damage. A qualified technician should...
Warranty, Maitenance, Services Guide
Page 31
...19 for Special Operating Conditions:1 ❑ Inspect nuts and bolts on chassis and body ❑ Replace automatic transmission fluid (Avalon, Camry, Camry Solara, Corolla, Sienna) ❑ Replace differential oil3 ❑ Replace manual transmission oil Dealer Service Verification: Date: Mileage: 1 2 Specific services ... pads/discs __ Differential oil __ Drive shaft boots __ Exhaust pipes and mountings __ Fuel lines and connections, fuel tank band and fuel tank vapor vent system hoses __ Fuel tank cap gasket __ Steering gear box __ Steering linkage and boots __ Transmission fluid or ...
...19 for Special Operating Conditions:1 ❑ Inspect nuts and bolts on chassis and body ❑ Replace automatic transmission fluid (Avalon, Camry, Camry Solara, Corolla, Sienna) ❑ Replace differential oil3 ❑ Replace manual transmission oil Dealer Service Verification: Date: Mileage: 1 2 Specific services ... pads/discs __ Differential oil __ Drive shaft boots __ Exhaust pipes and mountings __ Fuel lines and connections, fuel tank band and fuel tank vapor vent system hoses __ Fuel tank cap gasket __ Steering gear box __ Steering linkage and boots __ Transmission fluid or ...
Warranty, Maitenance, Services Guide
Page 35
... Replace engine coolant ❑ Replace engine oil and oil filter ❑ Replace air conditioning filter (Avalon, Camry) ❑ Replace spark plugs (Camry Solara with 1MZ-FE engine, ECHO, Sienna)2 ❑ Rotate tires (except MR2 Spyder) ❑ Inspect the following: __ Ball joints and dust covers...__ Drive belts4 __ Drive shaft boots __ Engine valve clearance __ Exhaust pipes and mountings __ Fuel lines and connections, fuel tank band and fuel tank vapor vent system hoses __ Fuel tank cap gasket __ Steering gear box __ Steering linkage and boots __ Transmission fluid or oil Additional ...
... Replace engine coolant ❑ Replace engine oil and oil filter ❑ Replace air conditioning filter (Avalon, Camry) ❑ Replace spark plugs (Camry Solara with 1MZ-FE engine, ECHO, Sienna)2 ❑ Rotate tires (except MR2 Spyder) ❑ Inspect the following: __ Ball joints and dust covers...__ Drive belts4 __ Drive shaft boots __ Engine valve clearance __ Exhaust pipes and mountings __ Fuel lines and connections, fuel tank band and fuel tank vapor vent system hoses __ Fuel tank cap gasket __ Steering gear box __ Steering linkage and boots __ Transmission fluid or oil Additional ...
Warranty, Maitenance, Services Guide
Page 39
... Inspect nuts and bolts on chassis and body Dealer Service Verification: Dealer Service Verification: ❑ Replace automatic transmission fluid (Avalon, Camry, Camry Solara, Corolla, Sienna) ❑ Replace differential oil3 ❑ Replace manual transmission oil Dealer Service Verification: Date: Mileage: Date: Mileage: Date: ... oil __ Drive belts __ Drive shaft boots __ Exhaust pipes and mountings __ Fuel lines and connections, fuel tank band and fuel tank vapor vent system hoses __ Fuel tank cap gasket __ Steering gear box __ Steering linkage and boots __ Transmission fluid ...
... Inspect nuts and bolts on chassis and body Dealer Service Verification: Dealer Service Verification: ❑ Replace automatic transmission fluid (Avalon, Camry, Camry Solara, Corolla, Sienna) ❑ Replace differential oil3 ❑ Replace manual transmission oil Dealer Service Verification: Date: Mileage: Date: Mileage: Date: ... oil __ Drive belts __ Drive shaft boots __ Exhaust pipes and mountings __ Fuel lines and connections, fuel tank band and fuel tank vapor vent system hoses __ Fuel tank cap gasket __ Steering gear box __ Steering linkage and boots __ Transmission fluid ...
Warranty, Maitenance, Services Guide
Page 43
...)3 __ Differential oil __ Drive belts __ Drive shaft boots __ Engine valve clearance __ Exhaust pipes and mountings __ Fuel lines and connections, fuel tank band and fuel tank vapor vent system hoses __ Fuel tank cap gasket __ Steering gear box __ Steering linkage and boots __ Transmission fluid or oil Additional Maintenance Items for...
...)3 __ Differential oil __ Drive belts __ Drive shaft boots __ Engine valve clearance __ Exhaust pipes and mountings __ Fuel lines and connections, fuel tank band and fuel tank vapor vent system hoses __ Fuel tank cap gasket __ Steering gear box __ Steering linkage and boots __ Transmission fluid or oil Additional Maintenance Items for...
Warranty, Maitenance, Services Guide
Page 47
... Sequoia, Tacoma, Tundra and 4Runner) __ Exhaust pipes and mountings __ Front differential oil (4WD models, Highlander and RAV4) __ Fuel lines and connections, fuel tank band and fuel tank vapor vent system hoses __ Fuel tank cap gasket __ Limited-slip differential oil (4WD Highlander, 4WD RAV4)3 __ Manual transmission oil (Tacoma, Tundra) __ Rear differential...
... Sequoia, Tacoma, Tundra and 4Runner) __ Exhaust pipes and mountings __ Front differential oil (4WD models, Highlander and RAV4) __ Fuel lines and connections, fuel tank band and fuel tank vapor vent system hoses __ Fuel tank cap gasket __ Limited-slip differential oil (4WD Highlander, 4WD RAV4)3 __ Manual transmission oil (Tacoma, Tundra) __ Rear differential...
Warranty, Maitenance, Services Guide
Page 51
... and 4Runner) __ Engine valve clearance __ Exhaust pipes and mountings __ Front differential oil (4WD models, Highlander, RAV4) __ Fuel lines and connections, fuel tank band and fuel tank vapor vent system hoses __ Fuel tank cap gasket __ Manual transmission oil (Tacoma, Tundra) __ Rear differential oil (all models except Highlander and RAV4) ❑ Inspect...
... and 4Runner) __ Engine valve clearance __ Exhaust pipes and mountings __ Front differential oil (4WD models, Highlander, RAV4) __ Fuel lines and connections, fuel tank band and fuel tank vapor vent system hoses __ Fuel tank cap gasket __ Manual transmission oil (Tacoma, Tundra) __ Rear differential oil (all models except Highlander and RAV4) ❑ Inspect...
Warranty, Maitenance, Services Guide
Page 55
... RAV4) ❑ Re-torque propeller shaft bolt (all models except Highlander and RAV4) ❑ Inspect the following: __ Fuel lines and connections, fuel tank band __ Automatic transmission fluid __ Ball joints and dust covers __ Brake lines and hoses __ Brake linings/drums and brake... and 4Runner) Dealer Service Verification: __ Exhaust pipes and mountings __ Front differential oil (4WD models, Highlander, RAV4) and fuel tank vapor vent system hoses __ Fuel tank cap gasket __ Limited-slip differential oil (4WD Highlander, 4WD RAV4)2 __ Manual transmission oil (Tacoma, Tundra) __ Rear ...
... RAV4) ❑ Re-torque propeller shaft bolt (all models except Highlander and RAV4) ❑ Inspect the following: __ Fuel lines and connections, fuel tank band __ Automatic transmission fluid __ Ball joints and dust covers __ Brake lines and hoses __ Brake linings/drums and brake... and 4Runner) Dealer Service Verification: __ Exhaust pipes and mountings __ Front differential oil (4WD models, Highlander, RAV4) and fuel tank vapor vent system hoses __ Fuel tank cap gasket __ Limited-slip differential oil (4WD Highlander, 4WD RAV4)2 __ Manual transmission oil (Tacoma, Tundra) __ Rear ...
Warranty, Maitenance, Services Guide
Page 59
... and 4Runner) __ Engine valve clearance __ Exhaust pipes and mountings __ Front differential oil (4WD models, Highlander, RAV4) __ Fuel lines and connections, fuel tank band and fuel tank vapor vent system hoses __ Fuel tank cap gasket __ Manual transmission oil (Tacoma, Tundra) __ Rear differential oil (all models except Highlander and RAV4) ❑ Inspect...
... and 4Runner) __ Engine valve clearance __ Exhaust pipes and mountings __ Front differential oil (4WD models, Highlander, RAV4) __ Fuel lines and connections, fuel tank band and fuel tank vapor vent system hoses __ Fuel tank cap gasket __ Manual transmission oil (Tacoma, Tundra) __ Rear differential oil (all models except Highlander and RAV4) ❑ Inspect...
Owners Manual
Page 9
'02 SOLARA_U (L/O 0108) SECTION Keys and Doors 1− 2 10 13 14 20 22 27 27 29 30 32 OPERATION OF INSTRUMENTS AND CONTROLS Keys ...Engine immobiliser system ...Side doors ...Power windows ...Trunk lid ...Hood ...Theft deterrent system ...Fuel tank cap ...Electric moon roof ...Convertible top ... 2002 MY SOLARA_U (OM33545U) 9
'02 SOLARA_U (L/O 0108) SECTION Keys and Doors 1− 2 10 13 14 20 22 27 27 29 30 32 OPERATION OF INSTRUMENTS AND CONTROLS Keys ...Engine immobiliser system ...Side doors ...Power windows ...Trunk lid ...Hood ...Theft deterrent system ...Fuel tank cap ...Electric moon roof ...Convertible top ... 2002 MY SOLARA_U (OM33545U) 9
Owners Manual
Page 29
... inside. When testing on the hood, also check that the fuel filler door is on the left side of the filler neck ...indicates that the system is activated when the battery terminal is suddenly removed. 2002 MY SOLARA_U (OM33545U) 29 The fumes are flammable. D When opening the...hood. When refueling, turn off or starts flashing. 3. In hot weather, fuel under pressure could cause injury by the If the tail light comes on your...not smoke, cause sparks or allow open the fuel filler door, pull the lever up. '02 SOLARA_U (L/O 0108) Fuel tank cap CANCELLING THE SYSTEM The system will be locked...
... inside. When testing on the hood, also check that the fuel filler door is on the left side of the filler neck ...indicates that the system is activated when the battery terminal is suddenly removed. 2002 MY SOLARA_U (OM33545U) 29 The fumes are flammable. D When opening the...hood. When refueling, turn off or starts flashing. 3. In hot weather, fuel under pressure could cause injury by the If the tail light comes on your...not smoke, cause sparks or allow open the fuel filler door, pull the lever up. '02 SOLARA_U (L/O 0108) Fuel tank cap CANCELLING THE SYSTEM The system will be locked...
Owners Manual
Page 30
...hear a click. D Use only a genuine Toyota fuel tank cap for replacement. It is not unusual to hear a slight swoosh when the cap is designed to prevent fuel spillage in case of an accident. Sliding operation Tilting operation 30 2002 MY SOLARA_U (OM33545U) Make sure the cap... is tightened securely to regulate fuel tank pressure. 2. CAUTION D Make sure the cap is tightened ...
...hear a click. D Use only a genuine Toyota fuel tank cap for replacement. It is not unusual to hear a slight swoosh when the cap is designed to prevent fuel spillage in case of an accident. Sliding operation Tilting operation 30 2002 MY SOLARA_U (OM33545U) Make sure the cap... is tightened securely to regulate fuel tank pressure. 2. CAUTION D Make sure the cap is tightened ...
Owners Manual
Page 100
...severe operating conditions, such as possible. '02 SOLARA_U (L/O 0108) Fuel gauge On inclines or curves, due to keep the tank over 1/4 full. If the fuel level approaches "E" or the low fuel level warning light comes on, fill the fuel tank as soon as : D Driving up a long hill on ..., the malfunction indicator lamp comes on . Fill the fuel tank immediately. If the fuel tank is turned off after high speed driving. 100 2002 MY SOLARA_U (OM33545U) The indicator lamp goes off . If your vehicle overheats, stop your Toyota dealer as soon as possible. The gauge indicates the ...
...severe operating conditions, such as possible. '02 SOLARA_U (L/O 0108) Fuel gauge On inclines or curves, due to keep the tank over 1/4 full. If the fuel level approaches "E" or the low fuel level warning light comes on, fill the fuel tank as soon as : D Driving up a long hill on ..., the malfunction indicator lamp comes on . Fill the fuel tank immediately. If the fuel tank is turned off after high speed driving. 100 2002 MY SOLARA_U (OM33545U) The indicator lamp goes off . If your vehicle overheats, stop your Toyota dealer as soon as possible. The gauge indicates the ...
Owners Manual
Page 104
...you depress the accelerator pedal more firmly and slowly, you to the "ON" position and goes off after the several driving trips. 104 2002 MY SOLARA_U (OM33545U) However, if a front passenger uses an additional seat cushion, the light may detect the pressure, causing the reminder... electrical system, or warning light system itself. Contact your Toyota dealer as soon as possible. D Loose fuel tank cap If the fuel tank cap is being discharged. D There is not loose... If the fuel tank is not empty or the fuel tank cap is a problem somewhere in the front passenger seat and...
...you depress the accelerator pedal more firmly and slowly, you to the "ON" position and goes off after the several driving trips. 104 2002 MY SOLARA_U (OM33545U) However, if a front passenger uses an additional seat cushion, the light may detect the pressure, causing the reminder... electrical system, or warning light system itself. Contact your Toyota dealer as soon as possible. D Loose fuel tank cap If the fuel tank cap is being discharged. D There is not loose... If the fuel tank is not empty or the fuel tank cap is a problem somewhere in the front passenger seat and...
Owners Manual
Page 174
... the first 800 km (500 miles). 174 2002 MY SOLARA_U (OM33545U) But following a few simple tips for concern. The special nozzle on pumps with unleaded fuel will fit it is severe, this can add... trailer during the first 300 km (200 miles). To help prevent gas station mix −ups, your vehicle: Fuel FUEL TYPE Your new vehicle must use leaded gasoline. D Do not drive over 88 km/h (55 mph). D Run... 4000 rpm. Use of ASTM D4814 in . If your Toyota dealer. Your vehicle does not need an elaborate break −in the U.S.A. Use of your Toyota has a smaller fuel tank opening.
... the first 800 km (500 miles). 174 2002 MY SOLARA_U (OM33545U) But following a few simple tips for concern. The special nozzle on pumps with unleaded fuel will fit it is severe, this can add... trailer during the first 300 km (200 miles). To help prevent gas station mix −ups, your vehicle: Fuel FUEL TYPE Your new vehicle must use leaded gasoline. D Do not drive over 88 km/h (55 mph). D Run... 4000 rpm. Use of ASTM D4814 in . If your Toyota dealer. Your vehicle does not need an elaborate break −in the U.S.A. Use of your Toyota has a smaller fuel tank opening.
Owners Manual
Page 176
z Take care not to drive your Toyota in foreign countries NOTICE z Do not use . FUEL TANK CAPACITY 70 L (18.5 gal., 15.4 lmp. Three −way catalytic converters Type A Type B 176 2002 MY SOLARA_U (OM33545U) gal.) If you plan to spill gasohol during refueling. It will cause fuel system damage or vehicle performance problems. z If driveability problems...
z Take care not to drive your Toyota in foreign countries NOTICE z Do not use . FUEL TANK CAPACITY 70 L (18.5 gal., 15.4 lmp. Three −way catalytic converters Type A Type B 176 2002 MY SOLARA_U (OM33545U) gal.) If you plan to spill gasohol during refueling. It will cause fuel system damage or vehicle performance problems. z If driveability problems...
Owners Manual
Page 234
...run down, the codes are taken. When the OBD system determines that a problem exists somewhere in the OBD system. Contact your Toyota dealer to be completely set. 234 2002 MY SOLARA_U (OM33545U) If your vehicle does not pass the I/M test even the malfunction indicator lamp does not come on, ... Emissions Inspection and Maintenance (I/M) programs Some states have if the malfunction indicator lamp not come on, your vehicle may not the I/M test as a loose fuel tank cap, your vehicle may not pass the I/M test. The OBD system monitors the operation of the emission control system.
...run down, the codes are taken. When the OBD system determines that a problem exists somewhere in the OBD system. Contact your Toyota dealer to be completely set. 234 2002 MY SOLARA_U (OM33545U) If your vehicle does not pass the I/M test even the malfunction indicator lamp does not come on, ... Emissions Inspection and Maintenance (I/M) programs Some states have if the malfunction indicator lamp not come on, your vehicle may not the I/M test as a loose fuel tank cap, your vehicle may not pass the I/M test. The OBD system monitors the operation of the emission control system.
Owners Manual
Page 271
...mm (in .): 1.1 (0.043) Drive belt tension measured with an Octane Rating of 91 (Research Octane Number 96) or higher is recommended. Fuel tank capacity, L (gal., Imp. BT−33−73F (used belt), Ibf: 1MZ−FE engine 115"20 5W-30 Preferred Temperature ...range anticipated before next oil change 2002 MY SOLARA_U (OM33545U) 271 Recommended oil viscosity (SAE): 3.8 (4.0, 3.3) 3.6 (3.8, 3.2) 4.7 (5.0, 4.1) 4.5 (4.8, 4.0) Spark plug gap, mm (in .): 2AZ−FE engine ...
...mm (in .): 1.1 (0.043) Drive belt tension measured with an Octane Rating of 91 (Research Octane Number 96) or higher is recommended. Fuel tank capacity, L (gal., Imp. BT−33−73F (used belt), Ibf: 1MZ−FE engine 115"20 5W-30 Preferred Temperature ...range anticipated before next oil change 2002 MY SOLARA_U (OM33545U) 271 Recommended oil viscosity (SAE): 3.8 (4.0, 3.3) 3.6 (3.8, 3.2) 4.7 (5.0, 4.1) 4.5 (4.8, 4.0) Spark plug gap, mm (in .): 2AZ−FE engine ...
Owners Manual
Page 287
... 91) or higher 1MZ−FE engine: UNLEADED gasoline, Octane Rating 87 (Research Octane Number 91) or higher. Tire pressure: See page 274. 2002 MY SOLARA_U (OM33545U) Publication No. Fuel tank capacity: 70 L (18.5 gal., 15.4 lmp.gal.) Engine oil: API grade SJ "Energy −Conserving", SL "Energy −Conserving" or ILSAC multigrade...
... 91) or higher 1MZ−FE engine: UNLEADED gasoline, Octane Rating 87 (Research Octane Number 91) or higher. Tire pressure: See page 274. 2002 MY SOLARA_U (OM33545U) Publication No. Fuel tank capacity: 70 L (18.5 gal., 15.4 lmp.gal.) Engine oil: API grade SJ "Energy −Conserving", SL "Energy −Conserving" or ILSAC multigrade...