Scheduled Maintenance Guide 4th Printing
Page 6
..., wiper operation, and clean all interior and exterior lights. and clean body and door drain holes. windshield washer fluid level. and lubricate upper and lower sliding door tracks, if equipped. safety warning lamps (brake, ABS, air bag, safety belt) for wear and proper air pressure, including spare. that the following basic maintenance...
..., wiper operation, and clean all interior and exterior lights. and clean body and door drain holes. windshield washer fluid level. and lubricate upper and lower sliding door tracks, if equipped. safety warning lamps (brake, ABS, air bag, safety belt) for wear and proper air pressure, including spare. that the following basic maintenance...
Scheduled Maintenance Guide 4th Printing
Page 12
... major problems. Ford Motor Company suggests the following multi-point inspection be performed at every visit ❑ Check and top up fluid levels: ❑ brake ❑ coolant recovery reservoir ❑ manual and automatic transmission ❑ power steering ❑ window washer (if equipped with ... - Check radiator, coolers, heater and air conditioning hoses. Inspect engine air filter. Check exhaust system for oil and fluid leaks. In order to ensure your vehicle checked regularly. Check battery performance. Inspect clutch operation, if equipped. 12 Scheduled Maintenance Keep ...
... major problems. Ford Motor Company suggests the following multi-point inspection be performed at every visit ❑ Check and top up fluid levels: ❑ brake ❑ coolant recovery reservoir ❑ manual and automatic transmission ❑ power steering ❑ window washer (if equipped with ... - Check radiator, coolers, heater and air conditioning hoses. Inspect engine air filter. Check exhaust system for oil and fluid leaks. In order to ensure your vehicle checked regularly. Check battery performance. Inspect clutch operation, if equipped. 12 Scheduled Maintenance Keep ...
Scheduled Maintenance Guide 4th Printing
Page 14
Inspect automatic transmission fluid level, if equipped with zerk fittings. Multi-point inspection (recommended) DEALER VALIDATION: RO#: DATE: P&A CODE: MILEAGE: 14 Scheduled Maintenance Normal Schedule Trucks, Fullsize Vans & SUVs ... ❑ optimal tire life. Multi-point inspection (recommended) DEALER VALIDATION: RO#: DATE: P&A CODE: MILEAGE: 15,000 miles Change engine oil and replace oil filter. Inspect brake pads/shoes/rotors/drums, brake lines & hoses, and parking...
Inspect automatic transmission fluid level, if equipped with zerk fittings. Multi-point inspection (recommended) DEALER VALIDATION: RO#: DATE: P&A CODE: MILEAGE: 14 Scheduled Maintenance Normal Schedule Trucks, Fullsize Vans & SUVs ... ❑ optimal tire life. Multi-point inspection (recommended) DEALER VALIDATION: RO#: DATE: P&A CODE: MILEAGE: 15,000 miles Change engine oil and replace oil filter. Inspect brake pads/shoes/rotors/drums, brake lines & hoses, and parking...
Scheduled Maintenance Guide 4th Printing
Page 16
... all other vehicles, if equipped with the Torqshift and 4R100 transmissions. Inspect automatic transmission/transaxle fluid level on vehicles equipped with dipstick. Inspect engine cooling system and hoses. Replace engine air filter. Consult your particular ... engine oil and replace oil filter. ❑ Inspect tires for your dealer for wear and rotate. ❑ Inspect brake pads/shoes/rotors/drums, brake lines & hoses, and parking brake system. Replace cabin air filter, if equipped. Rotation recommended for endplay and noise. Inspect steering linkage, ball joints, ...
... all other vehicles, if equipped with the Torqshift and 4R100 transmissions. Inspect automatic transmission/transaxle fluid level on vehicles equipped with dipstick. Inspect engine cooling system and hoses. Replace engine air filter. Consult your particular ... engine oil and replace oil filter. ❑ Inspect tires for your dealer for wear and rotate. ❑ Inspect brake pads/shoes/rotors/drums, brake lines & hoses, and parking brake system. Replace cabin air filter, if equipped. Rotation recommended for endplay and noise. Inspect steering linkage, ball joints, ...
Scheduled Maintenance Guide 4th Printing
Page 17
... hoses. Inspect and lubricate 4X4 front axle shaft U-joints (F250/350/450/550 and Excursion). lines & hoses, and parking brake system. Lubricate 4X2 ball joints and steering linkage if equipped with dipstick. Multi-point inspection (recommended) DEALER VALIDATION: Normal Schedule...engine oil and replace oil filter. ❑ Inspect tires for wear and rotate. ❑ Inspect automatic transmission fluid level, if ❑ Inspect brake pads/shoes/rotors/drums, brake equipped with zerk fittings. Multi-point inspection (recommended) DEALER VALIDATION: RO#: DATE: P&A CODE: MILEAGE: 45...
... hoses. Inspect and lubricate 4X4 front axle shaft U-joints (F250/350/450/550 and Excursion). lines & hoses, and parking brake system. Lubricate 4X2 ball joints and steering linkage if equipped with dipstick. Multi-point inspection (recommended) DEALER VALIDATION: Normal Schedule...engine oil and replace oil filter. ❑ Inspect tires for wear and rotate. ❑ Inspect automatic transmission fluid level, if ❑ Inspect brake pads/shoes/rotors/drums, brake equipped with zerk fittings. Multi-point inspection (recommended) DEALER VALIDATION: RO#: DATE: P&A CODE: MILEAGE: 45...
Scheduled Maintenance Guide 4th Printing
Page 19
... linkage if equipped with CVT. Lubricate 4X4 front hub needle bearings (Excursion). Inspect wheel ends for your dealer for endplay and noise. Change manual transmission fluid. Replace cabin air filter, if equipped. Replace climate-controlled seat filters if equipped (Navigator, Expedition and Aviator). Inspect steering linkage, ball joints, suspension and..., FULLSIZE VANS & SUVS 60,000 miles ❑ Change engine oil and replace oil filter. ❑ Inspect tires for wear and rotate. ❑ Inspect brake pads/shoes/rotors/drums, brake lines & hoses, and parking...
... linkage if equipped with CVT. Lubricate 4X4 front hub needle bearings (Excursion). Inspect wheel ends for your dealer for endplay and noise. Change manual transmission fluid. Replace cabin air filter, if equipped. Replace climate-controlled seat filters if equipped (Navigator, Expedition and Aviator). Inspect steering linkage, ball joints, suspension and..., FULLSIZE VANS & SUVS 60,000 miles ❑ Change engine oil and replace oil filter. ❑ Inspect tires for wear and rotate. ❑ Inspect brake pads/shoes/rotors/drums, brake lines & hoses, and parking...
Scheduled Maintenance Guide 4th Printing
Page 20
...lubricate 4X4 front axle shaft U-joints (F250/350/450/550 and Excursion). Rotation recommended for endplay and noise. DEALER VALIDATION: lines & hoses, and parking brake system. Inspect steering linkage, ball joints, suspension and, if equipped, half shafts, driveshaft and U-joints. Multi-point inspection (recommended) DEALER VALIDATION: RO#:... miles ❑ Change engine oil and replace oil filter. ❑ Inspect tires for wear and rotate. ❑ Inspect automatic transmission fluid level, if ❑ Inspect brake pads/shoes/rotors/drums, brake equipped with zerk fittings.
...lubricate 4X4 front axle shaft U-joints (F250/350/450/550 and Excursion). Rotation recommended for endplay and noise. DEALER VALIDATION: lines & hoses, and parking brake system. Inspect steering linkage, ball joints, suspension and, if equipped, half shafts, driveshaft and U-joints. Multi-point inspection (recommended) DEALER VALIDATION: RO#:... miles ❑ Change engine oil and replace oil filter. ❑ Inspect tires for wear and rotate. ❑ Inspect automatic transmission fluid level, if ❑ Inspect brake pads/shoes/rotors/drums, brake equipped with zerk fittings.
Scheduled Maintenance Guide 4th Printing
Page 22
.... Lubricate 4X2 ball joints and steering linkage if equipped with the Torqshift transmission. Rotation recommended for endplay and noise. Inspect automatic transmission/transaxle fluid level on vehicles equipped with dipstick. Consult your particular requirements. Replace the remote filter element on the vehicles equipped with zerk fittings. Replace climate... VANS & SUVS 90,000 miles ❑ Change engine oil and replace oil filter. ❑ Inspect tires for wear and rotate. ❑ Inspect brake pads/shoes/rotors/drums, brake lines & hoses, and parking...
.... Lubricate 4X2 ball joints and steering linkage if equipped with the Torqshift transmission. Rotation recommended for endplay and noise. Inspect automatic transmission/transaxle fluid level on vehicles equipped with dipstick. Consult your particular requirements. Replace the remote filter element on the vehicles equipped with zerk fittings. Replace climate... VANS & SUVS 90,000 miles ❑ Change engine oil and replace oil filter. ❑ Inspect tires for wear and rotate. ❑ Inspect brake pads/shoes/rotors/drums, brake lines & hoses, and parking...
Owner Guide 2nd Printing
Page 8
... Child Seat Tether Anchor Anti-Lock Brake System Child Seat Child Seat Lower Anchor Brake System Brake Fluid Non-Petroleum Based Speed Control Powertrain Malfunction Master Lighting Switch Hazard Warning Flasher Fog Lamps-Front Fuse Compartment Fuel Pump Reset Windshield Defrost/Demist Windshield Wash/Wipe Rear Window Defrost/Demist 8 2005 Lincoln LS (dew) Owners Guide (post-2002...
... Child Seat Tether Anchor Anti-Lock Brake System Child Seat Child Seat Lower Anchor Brake System Brake Fluid Non-Petroleum Based Speed Control Powertrain Malfunction Master Lighting Switch Hazard Warning Flasher Fog Lamps-Front Fuse Compartment Fuel Pump Reset Windshield Defrost/Demist Windshield Wash/Wipe Rear Window Defrost/Demist 8 2005 Lincoln LS (dew) Owners Guide (post-2002...
Owner Guide 2nd Printing
Page 11
... light is turned to the ON position. It will also sound when a malfunction in braking performance may occur. Illumination after releasing the parking brake indicates low brake fluid level and the brake system should be inspected immediately by your dealer immediately. Have the vehicle checked by your... the battery is turned to ON, continues to illuminate when ignition is not charging properly. 11 2005 Lincoln LS (dew) Owners Guide (post-2002-fmt) USA_English (fus) If the brake system warning light does not illuminate at this light fails to flash or remains on is illuminated....
... light is turned to the ON position. It will also sound when a malfunction in braking performance may occur. Illumination after releasing the parking brake indicates low brake fluid level and the brake system should be inspected immediately by your dealer immediately. Have the vehicle checked by your... the battery is turned to ON, continues to illuminate when ignition is not charging properly. 11 2005 Lincoln LS (dew) Owners Guide (post-2002-fmt) USA_English (fus) If the brake system warning light does not illuminate at this light fails to flash or remains on is illuminated....
Owner Guide 2nd Printing
Page 126
...fluid level • oil life in the FUEL, SETUP and STATUS controls. This message can only be displayed. • trunk status • exterior lamps (front and rear turn, brake, tail and side repeater lamp (if equipped) status) • Traction Control or AdvanceTrac (if equipped) 126 2005 Lincoln LS...the message center to select and reset functions shown in XX% • AC (cabin) filter XX% • engine temperature • brake fluid level • charging system • doors closed (driver and passenger side, front and rear). SETUP Press this control for four seconds....
...fluid level • oil life in the FUEL, SETUP and STATUS controls. This message can only be displayed. • trunk status • exterior lamps (front and rear turn, brake, tail and side repeater lamp (if equipped) status) • Traction Control or AdvanceTrac (if equipped) 126 2005 Lincoln LS...the message center to select and reset functions shown in XX% • AC (cabin) filter XX% • engine temperature • brake fluid level • charging system • doors closed (driver and passenger side, front and rear). SETUP Press this control for four seconds....
Owner Guide 2nd Printing
Page 131
... 2005 Lincoln LS (dew) Owners Guide (post-2002-fmt) USA_English (fus) Displayed when the driver's rear door is turned from OFF to RUN ENGINE POWER REDUCED. Stop the vehicle as soon as possible. Turn off the engine. Driver Controls Warnings Low brake fluid level Check tail lamps Check brake ... turn lamps Check Traction Control Check AdvanceTrac (if equipped) Trunk ajar Low washer fluid Check AC (cabin) filter Change oil soon Oil change required Service park brake Apply park brake Foot on , contact your dealer as soon as possible. Displayed when the engine is not...
... 2005 Lincoln LS (dew) Owners Guide (post-2002-fmt) USA_English (fus) Displayed when the driver's rear door is turned from OFF to RUN ENGINE POWER REDUCED. Stop the vehicle as soon as possible. Turn off the engine. Driver Controls Warnings Low brake fluid level Check tail lamps Check brake ... turn lamps Check Traction Control Check AdvanceTrac (if equipped) Trunk ajar Low washer fluid Check AC (cabin) filter Change oil soon Oil change required Service park brake Apply park brake Foot on , contact your dealer as soon as possible. Displayed when the engine is not...
Owner Guide 2nd Printing
Page 133
... out. Displayed when the trunk is not monitored. Indicates the washer fluid reservoir is less than one is burned out. Displayed when the A/C cabin filter life remaining is between 5% 133 2005 Lincoln LS (dew) Owners Guide (post-2002-fmt) USA_English (fus) CHECK... SIDE REPEATER LAMPS (if equipped). CHECK TRACTION CONTROL. TRUNK AJAR. LOW WASHER FLUID. Check the lamps as soon as possible. CHECK A/C (cabin) FILTER. Driver Controls LOW BRAKE FLUID. Displayed when the brake lamps...
... out. Displayed when the trunk is not monitored. Indicates the washer fluid reservoir is less than one is burned out. Displayed when the A/C cabin filter life remaining is between 5% 133 2005 Lincoln LS (dew) Owners Guide (post-2002-fmt) USA_English (fus) CHECK... SIDE REPEATER LAMPS (if equipped). CHECK TRACTION CONTROL. TRUNK AJAR. LOW WASHER FLUID. Check the lamps as soon as possible. CHECK A/C (cabin) FILTER. Driver Controls LOW BRAKE FLUID. Displayed when the brake lamps...
Owner Guide 2nd Printing
Page 278
... the handle. 3. Maintenance and Specifications OPENING THE HOOD 1. IDENTIFYING COMPONENTS IN THE ENGINE COMPARTMENT 3.0L DOHC V6 engine 1 2 3 4 8 1. 2. 3. 4. 7 5. 6. 7. 8. 6 5 Engine oil filler cap Engine oil dipstick Brake fluid reservoir Engine coolant reservoir Air filter assembly Power steering fluid reservoir Windshield washer fluid reservoir Power distribution box 278 2005 Lincoln LS (dew) Owners Guide (post-2002-fmt) USA_English (fus)
... the handle. 3. Maintenance and Specifications OPENING THE HOOD 1. IDENTIFYING COMPONENTS IN THE ENGINE COMPARTMENT 3.0L DOHC V6 engine 1 2 3 4 8 1. 2. 3. 4. 7 5. 6. 7. 8. 6 5 Engine oil filler cap Engine oil dipstick Brake fluid reservoir Engine coolant reservoir Air filter assembly Power steering fluid reservoir Windshield washer fluid reservoir Power distribution box 278 2005 Lincoln LS (dew) Owners Guide (post-2002-fmt) USA_English (fus)
Owner Guide 2nd Printing
Page 279
Engine oil filler cap Engine oil dipstick Brake fluid reservoir Engine coolant reservoir 5. 6. 7. 8. Air filter assembly Power steering fluid reservoir Windshield washer fluid reservoir Power distribution box WINDSHIELD WASHER FLUID Add fluid to Lubricant specifications in this chapter. 279 2005 Lincoln LS (dew) Owners Guide (post-2002-fmt) USA_English (fus) Only use a washer fluid that meets Ford specification WSB-M8B16-A2...
Engine oil filler cap Engine oil dipstick Brake fluid reservoir Engine coolant reservoir 5. 6. 7. 8. Air filter assembly Power steering fluid reservoir Windshield washer fluid reservoir Power distribution box WINDSHIELD WASHER FLUID Add fluid to Lubricant specifications in this chapter. 279 2005 Lincoln LS (dew) Owners Guide (post-2002-fmt) USA_English (fus) Only use a washer fluid that meets Ford specification WSB-M8B16-A2...
Owner Guide 2nd Printing
Page 302
...-approved automatic transmission fluid may affect transmission operation and result in this chapter. 302 2005 Lincoln LS (dew) Owners Guide (post-2002-fmt) USA_English (fus) If the fluid levels are outside of the normal operating range the performance of fluid used . seek service from your brake system could be added... the air filter element. Refer to Motorcraft part numbers in this chapter. Maintenance and Specifications BRAKE FLUID RESERVOIR The fluid level will drop slowly as the brakes wear, and will rise when the brake components are within the normal operating range;
...-approved automatic transmission fluid may affect transmission operation and result in this chapter. 302 2005 Lincoln LS (dew) Owners Guide (post-2002-fmt) USA_English (fus) If the fluid levels are outside of the normal operating range the performance of fluid used . seek service from your brake system could be added... the air filter element. Refer to Motorcraft part numbers in this chapter. Maintenance and Specifications BRAKE FLUID RESERVOIR The fluid level will drop slowly as the brakes wear, and will rise when the brake components are within the normal operating range;
Owner Guide 2nd Printing
Page 305
... V6 engine 3.9L-4V V8 engine 11.2 quarts (10.6L) 11.9 quarts (11.3L) 305 2005 Lincoln LS (dew) Owners Guide (post-2002-fmt) USA_English (fus) REFILL CAPACITIES Fluid Brake fluid Ford Part Name Motorcraft High Performance DOT 3 Motor Vehicle Brake Fluid 1 Motorcraft SAE 5W-20 Premium Synthetic Blend Motor Oil (US) Motorcraft SAE 5W-20 Super Premium...
... V6 engine 3.9L-4V V8 engine 11.2 quarts (10.6L) 11.9 quarts (11.3L) 305 2005 Lincoln LS (dew) Owners Guide (post-2002-fmt) USA_English (fus) REFILL CAPACITIES Fluid Brake fluid Ford Part Name Motorcraft High Performance DOT 3 Motor Vehicle Brake Fluid 1 Motorcraft SAE 5W-20 Premium Synthetic Blend Motor Oil (US) Motorcraft SAE 5W-20 Super Premium...
Owner Guide 2nd Printing
Page 306
... and the API Certification mark. 306 18.0 gallons (68.0L) 11.9 quarts (11.2L) 5 2005 Lincoln LS (dew) Owners Guide (post-2002-fmt) USA_English (fus) Fluid level should be checked or changed any time the rear axle has been submerged in this chapter. These ...MAX line on reservoir 2.5-2.7 pints (1.2-1.3L) Fuel tank Transmission fluid 4 All Motorcraft Automatic MERCONV (5R55S) ATF Windshield Motorcraft All Fill to line on washer fluid Premium reservoir Windshield Washer Concentrate 1 Use only brake fluids certified to determine the correct service interval. 5 Approximate dry ...
... and the API Certification mark. 306 18.0 gallons (68.0L) 11.9 quarts (11.2L) 5 2005 Lincoln LS (dew) Owners Guide (post-2002-fmt) USA_English (fus) Fluid level should be checked or changed any time the rear axle has been submerged in this chapter. These ...MAX line on reservoir 2.5-2.7 pints (1.2-1.3L) Fuel tank Transmission fluid 4 All Motorcraft Automatic MERCONV (5R55S) ATF Windshield Motorcraft All Fill to line on washer fluid Premium reservoir Windshield Washer Concentrate 1 Use only brake fluids certified to determine the correct service interval. 5 Approximate dry ...
Owner Guide 2nd Printing
Page 307
Maintenance and Specifications LUBRICANT SPECIFICATIONS Ford part name Brake fluid Motorcraft High Performance DOT 3 Motor Vehicle Brake Fluid 1 Door Silicone weatherstrips Lubricant Door latch, hood Multi-Purpose Grease latch, auxiliary hood latch, door hinges, striker plates, seat tracks and fuel filler door hinge ... NM) XO-5W20-QSP (US) CXO-5W20-LSP12 (Canada) WSS-M97B51-A1 WSS-M2C153-H with API Certification Mark Lock cylinders Motorcraft XL-1 none Power steering fluid XT-2-QDX MERCON 307 2005 Lincoln LS (dew) Owners Guide (post-2002-fmt) USA_English (fus)
Maintenance and Specifications LUBRICANT SPECIFICATIONS Ford part name Brake fluid Motorcraft High Performance DOT 3 Motor Vehicle Brake Fluid 1 Door Silicone weatherstrips Lubricant Door latch, hood Multi-Purpose Grease latch, auxiliary hood latch, door hinges, striker plates, seat tracks and fuel filler door hinge ... NM) XO-5W20-QSP (US) CXO-5W20-LSP12 (Canada) WSS-M97B51-A1 WSS-M2C153-H with API Certification Mark Lock cylinders Motorcraft XL-1 none Power steering fluid XT-2-QDX MERCON 307 2005 Lincoln LS (dew) Owners Guide (post-2002-fmt) USA_English (fus)
Owner Guide 2nd Printing
Page 308
... Premium Windshield Washer Concentrate Ford part number XY-75W140-QL Ford specification WSL-M2C192-A Automatic transmission fluid Windshield washer fluid XT-5-QM MERCONV ZC-32-A WSB-M8B16-A2 Use only brake fluids certified to determine the correct service interval. 3 2 1 ENGINE DATA Engine Displacement Required fuel ...-4V V8 engine 241 cid (3 949 cc) 91 octane 1-5-4-2-6-3-7-8 Coil on plug 0.040-0.044 inch (1.0-1.1mm) 10.75:1 308 2005 Lincoln LS (dew) Owners Guide (post-2002-fmt) USA_English (fus) Refer to the scheduled maintenance information to meet Ford specifications.
... Premium Windshield Washer Concentrate Ford part number XY-75W140-QL Ford specification WSL-M2C192-A Automatic transmission fluid Windshield washer fluid XT-5-QM MERCONV ZC-32-A WSB-M8B16-A2 Use only brake fluids certified to determine the correct service interval. 3 2 1 ENGINE DATA Engine Displacement Required fuel ...-4V V8 engine 241 cid (3 949 cc) 91 octane 1-5-4-2-6-3-7-8 Coil on plug 0.040-0.044 inch (1.0-1.1mm) 10.75:1 308 2005 Lincoln LS (dew) Owners Guide (post-2002-fmt) USA_English (fus) Refer to the scheduled maintenance information to meet Ford specifications.