Scheduled Maintenance Guide 3rd Printing
Page 32
...and adjust bearings Inspect and lubricate steering linkage (E and F Series, Expedition, Navigator, Excursion) Additional services for: 4x4 Vehicles Change front axle lubricant Change transfer case fluid Additional services for wear and rotate Replace engine air filter Replace fuel filter* Replace cabin air filter, if equipped... Replace orange engine coolant, if equipped Change automatic transmission/transaxle fluid and filter Replace rear axle lubricant on all recommended maintenance services be performed at the indicated intervals and the maintenance be recorded. 32
...and adjust bearings Inspect and lubricate steering linkage (E and F Series, Expedition, Navigator, Excursion) Additional services for: 4x4 Vehicles Change front axle lubricant Change transfer case fluid Additional services for wear and rotate Replace engine air filter Replace fuel filter* Replace cabin air filter, if equipped... Replace orange engine coolant, if equipped Change automatic transmission/transaxle fluid and filter Replace rear axle lubricant on all recommended maintenance services be performed at the indicated intervals and the maintenance be recorded. 32
Scheduled Maintenance Guide 3rd Printing
Page 33
... above 21 Celsius (70 degrees Fahrenheit) ambient and wide open throttle for life. Non-synthetic rear axle lubricants should be changed unless a leak is suspected, service is required or the axle assembly has been submerged in water. The axle lubricant should be replaced every 3,000 miles or 3 months, whichever occurs first, during extended trailer...
... above 21 Celsius (70 degrees Fahrenheit) ambient and wide open throttle for life. Non-synthetic rear axle lubricants should be changed unless a leak is suspected, service is required or the axle assembly has been submerged in water. The axle lubricant should be replaced every 3,000 miles or 3 months, whichever occurs first, during extended trailer...
Scheduled Maintenance Guide 3rd Printing
Page 34
... part number FITZ-19580-B or equivalent. The rear axle lubricant should be changed anytime the axle has been submerged in water. Police and Taxi Vehicle Axle Maintenance Replace rear axle lubricant every 160,000 km (100,000 miles). The rear axle lubricant should be observed when the vehicles are operated...50,000 miles. For F-450 and F-550 trucks operated at or near maximum Gross Vehicle Weight Ratings, the rear axle lubricant should be changed anytime the axle has been submerged in water. Add four ounces of additive friction modifier C8AZ-19B546-A (EST-M2C118-A) or equivalent...
... part number FITZ-19580-B or equivalent. The rear axle lubricant should be changed anytime the axle has been submerged in water. Police and Taxi Vehicle Axle Maintenance Replace rear axle lubricant every 160,000 km (100,000 miles). The rear axle lubricant should be observed when the vehicles are operated...50,000 miles. For F-450 and F-550 trucks operated at or near maximum Gross Vehicle Weight Ratings, the rear axle lubricant should be changed anytime the axle has been submerged in water. Add four ounces of additive friction modifier C8AZ-19B546-A (EST-M2C118-A) or equivalent...
Scheduled Maintenance Guide 3rd Printing
Page 36
... miles As required As required Off-road operation Change engine oil and replace oil filter Replace fuel filter Change automatic transmission fluid Change rear axle lubricant (F-450 and F-550 only) Change transfer case fluid Replace engine air filter Replace cabin air filter Every 30,000 miles Change... automatic transmission fluid Every 50,000 miles Change rear axle lubricant (F-450 and F-550 only) Every 60,000 miles Change transfer case fluid As required Replace cabin air-filter As required Inspect...
... miles As required As required Off-road operation Change engine oil and replace oil filter Replace fuel filter Change automatic transmission fluid Change rear axle lubricant (F-450 and F-550 only) Change transfer case fluid Replace engine air filter Replace cabin air filter Every 30,000 miles Change... automatic transmission fluid Every 50,000 miles Change rear axle lubricant (F-450 and F-550 only) Every 60,000 miles Change transfer case fluid As required Replace cabin air-filter As required Inspect...
Owner Guide 1st Printing
Page 126
... if the Overdrive mode is desired. This loss of other than the manufacturer's specified size tires on a Traction-Lok rear axle could result in a permanent reduction in the Trailer Towing chapter. Upshifts can be noticeable to the driver. Under normal conditions, the... Traction-Lok axle functions like a standard rear axle. Selecting 1 (Low) at higher speeds causes the transmission to shift to a lower gear, and will no longer be illuminated. Driving...
... if the Overdrive mode is desired. This loss of other than the manufacturer's specified size tires on a Traction-Lok rear axle could result in a permanent reduction in the Trailer Towing chapter. Upshifts can be noticeable to the driver. Under normal conditions, the... Traction-Lok axle functions like a standard rear axle. Selecting 1 (Low) at higher speeds causes the transmission to shift to a lower gear, and will no longer be illuminated. Driving...
Owner Guide 1st Printing
Page 128
... Label, found on the certification label. Do not tow a trailer until your vehicle including both gross vehicle weight and front and rear gross axle weight rating limits. If you limit your vehicle, (potentially including weight added to the vehicle and/or personal injury. Under no more... door, lists several important vehicle weight rating limitations. You may be exceeded. You should weigh no circumstance should not exceed the front axle reserve capacity (FARC). The weight of cargo carried). Do not use replacement tires with a higher limit than the originals because they may...
... Label, found on the certification label. Do not tow a trailer until your vehicle including both gross vehicle weight and front and rear gross axle weight rating limits. If you limit your vehicle, (potentially including weight added to the vehicle and/or personal injury. Under no more... door, lists several important vehicle weight rating limitations. You may be exceeded. You should weigh no circumstance should not exceed the front axle reserve capacity (FARC). The weight of cargo carried). Do not use replacement tires with a higher limit than the originals because they may...
Owner Guide 1st Printing
Page 131
... that is unknown. Water may also enter your engine's air intake and severely damage your engine may stall. Replace the rear axle lubricant anytime the axle has been submerged in water. DRIVING THROUGH WATER Do not drive quickly through deep water where the transmission/transmission vent tube is... especially if the depth is higher than the bottom of the hubs (for trucks) or the bottom of the wheel rims (for cars). Rear axle lubricant quantities are not to the trailer before backing the trailer into the transmission and cause internal transmission damage. 131 If driving through ...
... that is unknown. Water may also enter your engine's air intake and severely damage your engine may stall. Replace the rear axle lubricant anytime the axle has been submerged in water. DRIVING THROUGH WATER Do not drive quickly through deep water where the transmission/transmission vent tube is... especially if the depth is higher than the bottom of the hubs (for trucks) or the bottom of the wheel rims (for cars). Rear axle lubricant quantities are not to the trailer before backing the trailer into the transmission and cause internal transmission damage. 131 If driving through ...
Owner Guide 1st Printing
Page 196
... Use only brake fluids certified to determine the correct service interval. 3 Indicates only approximate dry-fill capacity. The amount of Traction-Lok rear axle. For limousine, use 2.4L (5.0 pints) of the filler hole. 196 Service refill capacities are not interchangeable. Refer to Adding engine ... DO NOT USE Ford Extended Life Engine Coolant (orange in this chapter. Refer to 9/16 inch) below the bottom of Motorcraft Synthetic Rear Axle Lubricant F1TZ-19780-B or equivalent meeting Ford specification EST-M2C118-A for normal service. DOT 3 fluid is not available, DOT 4 fluid ...
... Use only brake fluids certified to determine the correct service interval. 3 Indicates only approximate dry-fill capacity. The amount of Traction-Lok rear axle. For limousine, use 2.4L (5.0 pints) of the filler hole. 196 Service refill capacities are not interchangeable. Refer to Adding engine ... DO NOT USE Ford Extended Life Engine Coolant (orange in this chapter. Refer to 9/16 inch) below the bottom of Motorcraft Synthetic Rear Axle Lubricant F1TZ-19780-B or equivalent meeting Ford specification EST-M2C118-A for normal service. DOT 3 fluid is not available, DOT 4 fluid ...
Owner Guide 1st Printing
Page 197
...Door weatherstrips Engine coolant Engine oil Hinges, latches, striker plates, fuel filler door hinge and seat tracks Lock cylinders Power steering fluid Automatic transmission (4R70W) Rear Axle Lubricant 2 Windshield washer fluid F7AZ-19G208-BA ESR-M13P4-A and F5AZ-19553-AA E2FZ-19549-AA ESE-M97B44-A (in Canada, Motorcraft CXC-8-B) XO-... MERCON MERCONV WSP-M2C197-A Penetrating and Lock Lubricant Motorcraft MERCON ATF Motorcraft MERCONV ATF Motorcraft SAE 80W-90 Premium Rear Axle Lubricant Ultra-clear Windshield Washer Concentrate C9AZ-19550-AC ESR-M17P5-A 197
...Door weatherstrips Engine coolant Engine oil Hinges, latches, striker plates, fuel filler door hinge and seat tracks Lock cylinders Power steering fluid Automatic transmission (4R70W) Rear Axle Lubricant 2 Windshield washer fluid F7AZ-19G208-BA ESR-M13P4-A and F5AZ-19553-AA E2FZ-19549-AA ESE-M97B44-A (in Canada, Motorcraft CXC-8-B) XO-... MERCON MERCONV WSP-M2C197-A Penetrating and Lock Lubricant Motorcraft MERCON ATF Motorcraft MERCONV ATF Motorcraft SAE 80W-90 Premium Rear Axle Lubricant Ultra-clear Windshield Washer Concentrate C9AZ-19550-AC ESR-M17P5-A 197
Owner Guide 1st Printing
Page 198
...3 is recommended. For limousine, use 2.2-2.4L (4.75-5.0 pints) of Motorcraft Synthetic High Performance Rear Axle Lubricant F1TZ-19780-B or equivalent meeting Ford specification EST-M2C118-A for complete refill of Traction-Lok rear axles. Front (5) Track - DOT 3 fluid is not available, DOT 4 fluid can be used.... 2 Add 118 ml (4 oz.) of Additive Friction Modifier C8AZ-19B546-A or equivalent meeting Ford Specification WSL-M2C192-A for complete refill of rear axles. Rear a Denotes long wheel base mm (in) 5 469 (215.3)/5 621 (221.3)a 1 987 (78.2) 1 472 (58.0) 2 990 (117.7)/3 142 ...
...3 is recommended. For limousine, use 2.2-2.4L (4.75-5.0 pints) of Motorcraft Synthetic High Performance Rear Axle Lubricant F1TZ-19780-B or equivalent meeting Ford specification EST-M2C118-A for complete refill of Traction-Lok rear axles. Front (5) Track - DOT 3 fluid is not available, DOT 4 fluid can be used.... 2 Add 118 ml (4 oz.) of Additive Friction Modifier C8AZ-19B546-A or equivalent meeting Ford Specification WSL-M2C192-A for complete refill of rear axles. Rear a Denotes long wheel base mm (in) 5 469 (215.3)/5 621 (221.3)a 1 987 (78.2) 1 472 (58.0) 2 990 (117.7)/3 142 ...
Owner Guide 1st Printing
Page 211
that are equipped with compass and temperature display) Protection and appearance equipment Air bag anti-theft locks Car/truck covers Carpet floor mats Cleaners, waxes and polishes Flat splash guards Lubricants and oils Molded splash guards Molded vinyl ...specific weight information. • The Federal Communications Commission (FCC) and Canadian Radio Telecommunications Commission (CRTC) regulate the use of the front or rear axle (GVWR or GAWR as two-way radios, telephones and theft alarms - Customer assistance Comfort and convenience Cargo nets Cargo organizers Engine block heaters ...
that are equipped with compass and temperature display) Protection and appearance equipment Air bag anti-theft locks Car/truck covers Carpet floor mats Cleaners, waxes and polishes Flat splash guards Lubricants and oils Molded splash guards Molded vinyl ...specific weight information. • The Federal Communications Commission (FCC) and Canadian Radio Telecommunications Commission (CRTC) regulate the use of the front or rear axle (GVWR or GAWR as two-way radios, telephones and theft alarms - Customer assistance Comfort and convenience Cargo nets Cargo organizers Engine block heaters ...
Owner Guide 1st Printing
Page 214
...overdrive ...124 fluid, adding ...164 fluid, checking ...164 fluid, refill capacities ...195 fluid, specification ...198 Auxiliary power point ...54 Axle lubricant specifications ...197,198 refill capacities ...195 traction lok ...126 Battery ...166 acid, treating emergencies ...166 charging system warning light ......Certification Label ...200 Child safety restraints ...106 child safety belts ...106 Child safety seats ...107 in front seat ...109 in rear seat ...109 ISOFIX attachments ...94 Cleaning your vehicle ...190 engine compartment ...193 exterior ...191,192 exterior lamps ...192 instrument...
...overdrive ...124 fluid, adding ...164 fluid, checking ...164 fluid, refill capacities ...195 fluid, specification ...198 Auxiliary power point ...54 Axle lubricant specifications ...197,198 refill capacities ...195 traction lok ...126 Battery ...166 acid, treating emergencies ...166 charging system warning light ......Certification Label ...200 Child safety restraints ...106 child safety belts ...106 Child safety seats ...107 in front seat ...109 in rear seat ...109 ISOFIX attachments ...94 Cleaning your vehicle ...190 engine compartment ...193 exterior ...191,192 exterior lamps ...192 instrument...
Owner Guide 1st Printing
Page 218
... ...171 Towing ...128,172 trailer towing ...128 wrecker ...149 Traction control ...120 active light ...13 how to enable/disable ...121 off light ...12 Traction-lok rear axle ...126 Transmission ...123 fluid, checking and adding (automatic) ...164 fluid, refill capacities ...195 lubricant specifications ...197,198 Trunk ...83 remote release ...66,73 Turn signal...
... ...171 Towing ...128,172 trailer towing ...128 wrecker ...149 Traction control ...120 active light ...13 how to enable/disable ...121 off light ...12 Traction-lok rear axle ...126 Transmission ...123 fluid, checking and adding (automatic) ...164 fluid, refill capacities ...195 lubricant specifications ...197,198 Trunk ...83 remote release ...66,73 Turn signal...