Scheduled Maintenance Guide 3rd Printing
Page 7
... or lubricants used. The owner maintenance service checks are provided in the Owner's Guide. Any adverse condition should be performed by warranties so you may be brought to Mileage Intervals for wear and proper air pressure engine oil fluid level windshield washer solvent fluid level and drain fuel/water separator (diesel vehicles...
... or lubricants used. The owner maintenance service checks are provided in the Owner's Guide. Any adverse condition should be performed by warranties so you may be brought to Mileage Intervals for wear and proper air pressure engine oil fluid level windshield washer solvent fluid level and drain fuel/water separator (diesel vehicles...
Scheduled Maintenance Guide 3rd Printing
Page 35
Special Operating Conditions Special Operating Conditions Items Needing Special Attention If you operate your Ford/Lincoln/Mercury primarily in heavy commercial use such as delivery, taxi, patrol car or livery Every 3,000 miles or 3 months Change engine oil and replace oil filter Lube front lower ...and adjust bearings Every 60,000 miles Replace spark plugs Change transfer case fluid As required Replace cabin air filter 35 For specific recommendations, see your vehicle under these conditions, it is not necessary to have some items maintained more frequently. Towing a trailer or using a...
Special Operating Conditions Special Operating Conditions Items Needing Special Attention If you operate your Ford/Lincoln/Mercury primarily in heavy commercial use such as delivery, taxi, patrol car or livery Every 3,000 miles or 3 months Change engine oil and replace oil filter Lube front lower ...and adjust bearings Every 60,000 miles Replace spark plugs Change transfer case fluid As required Replace cabin air filter 35 For specific recommendations, see your vehicle under these conditions, it is not necessary to have some items maintained more frequently. Towing a trailer or using a...
Scheduled Maintenance Guide 3rd Printing
Page 36
Special Operating Conditions Special Operating Conditions Operating in dusty conditions such as unpaved or dusty roads Every 3,000 miles or 3 months Every 15,000 miles Every 30,000 miles Every 50,000 miles Every 60,... replace oil filter Replace fuel filter Change automatic transmission fluid Change rear axle lubricant (F-450 and F-550 only) Change transfer case fluid Replace engine air filter Replace cabin air filter Every 30,000 miles Change automatic transmission fluid Every 50,000 miles Change rear axle lubricant (F-450 and F-550 only) Every 60...
Special Operating Conditions Special Operating Conditions Operating in dusty conditions such as unpaved or dusty roads Every 3,000 miles or 3 months Every 15,000 miles Every 30,000 miles Every 50,000 miles Every 60,... replace oil filter Replace fuel filter Change automatic transmission fluid Change rear axle lubricant (F-450 and F-550 only) Change transfer case fluid Replace engine air filter Replace cabin air filter Every 30,000 miles Change automatic transmission fluid Every 50,000 miles Change rear axle lubricant (F-450 and F-550 only) Every 60...
Owner Guide 1st Printing
Page 9
...three driving cycles without these or any other vehicle components, possibly causing a fire. Under engine misfire conditions, excessive exhaust temperatures could damage your safety belts. Air bag readiness Momentarily illuminates when the ignition is required. Safety belt Momentarily illuminates when the ignition is ... at the first available opportunity. For more information, refer to the Seating and safety restraints chapter. AIR BAG 9 Instrumentation 2. These temporary malfunctions can be corrected by mixed city/highway driving.) No additional vehicle service is turned ON.
...three driving cycles without these or any other vehicle components, possibly causing a fire. Under engine misfire conditions, excessive exhaust temperatures could damage your safety belts. Air bag readiness Momentarily illuminates when the ignition is required. Safety belt Momentarily illuminates when the ignition is ... at the first available opportunity. For more information, refer to the Seating and safety restraints chapter. AIR BAG 9 Instrumentation 2. These temporary malfunctions can be corrected by mixed city/highway driving.) No additional vehicle service is turned ON.
Owner Guide 1st Printing
Page 13
...refer to the OFF position. For more information on , the transmission does SPEED CONTROL COMPASS not operate in the Controls TRAC OFF AIR SUSPENSION SLOWLY and Features chapter, has been km pushed turning the transmission overdrive function OFF. Trac active Illuminates when the Traction Control... COMPASS TRUNK AJAR DOOR AJAR TRAC OFF AIR SUSPENSION km O/D OFF TRAC ACTIVE SPEED CONTROL CIRCLE SLOWLY COMPASS 13 The light may also flash steadily if a transmission malfunction is on the traction control system, refer to limit a wheelspin condition. When the O/D OFF TRAC ACTIVE light...
...refer to the OFF position. For more information on , the transmission does SPEED CONTROL COMPASS not operate in the Controls TRAC OFF AIR SUSPENSION SLOWLY and Features chapter, has been km pushed turning the transmission overdrive function OFF. Trac active Illuminates when the Traction Control... COMPASS TRUNK AJAR DOOR AJAR TRAC OFF AIR SUSPENSION km O/D OFF TRAC ACTIVE SPEED CONTROL CIRCLE SLOWLY COMPASS 13 The light may also flash steadily if a transmission malfunction is on the traction control system, refer to limit a wheelspin condition. When the O/D OFF TRAC ACTIVE light...
Owner Guide 1st Printing
Page 18
km Magnetic or metallic objects placed in normal conditions. Refer to Compass zone adjustment. 18 This variation is four degrees between adjacent zones and will eliminate this control to reset the selected message center ... (zones) have a magnetic north compass point that varies slightly from the northerly direction on or near large CIRCLE buildings, bridges, power lines and TRAC OFF AIR SUSPENSION SLOWLY powerful broadcast antenna. If the compass still appears to zero. (The only functions which can be reset are FUEL ECON and TRIP A or...
km Magnetic or metallic objects placed in normal conditions. Refer to Compass zone adjustment. 18 This variation is four degrees between adjacent zones and will eliminate this control to reset the selected message center ... (zones) have a magnetic north compass point that varies slightly from the northerly direction on or near large CIRCLE buildings, bridges, power lines and TRAC OFF AIR SUSPENSION SLOWLY powerful broadcast antenna. If the compass still appears to zero. (The only functions which can be reset are FUEL ECON and TRIP A or...
Owner Guide 1st Printing
Page 19
... the vehicle in for your geographic location by referring to 4 seconds until CIRCLE CIRCLE SLOWLY is displayed on the TRAC OFF AIR SUSPENSION SLOWLY message center. Turn ignition to show the current zone setting. 5. Compass calibration adjustment Perform this adjustment in an open... 8 9 message center display changes to the ON position. 11 4. For optimum calibration, turn off all electrical accessories (heater/air conditioning, wipers, etc.) and make sure all vehicle doors are in a SPEED CONTROL COMPASS circle (less than ten seconds. Instrumentation Compass zone adjustment ...
... the vehicle in for your geographic location by referring to 4 seconds until CIRCLE CIRCLE SLOWLY is displayed on the TRAC OFF AIR SUSPENSION SLOWLY message center. Turn ignition to show the current zone setting. 5. Compass calibration adjustment Perform this adjustment in an open... 8 9 message center display changes to the ON position. 11 4. For optimum calibration, turn off all electrical accessories (heater/air conditioning, wipers, etc.) and make sure all vehicle doors are in a SPEED CONTROL COMPASS circle (less than ten seconds. Instrumentation Compass zone adjustment ...
Owner Guide 1st Printing
Page 25
...When in the display window. The EATC system will automatically determine fan speed, airflow location and if outside air or recirculated air is turned off Press OFF. If unusual conditions exist (i.e.-window fogging, etc.), the manual override controls allow you to select airflow locations and the fan control...location will only operate when the vehicle is pressed. The selected temperature and the word AUTO will appear in AUTO and weather conditions require heat, air will be sent to the floor area. Controls and features Turning the EATC on Press AUTO, any of the override controls...
...When in the display window. The EATC system will automatically determine fan speed, airflow location and if outside air or recirculated air is turned off Press OFF. If unusual conditions exist (i.e.-window fogging, etc.), the manual override controls allow you to select airflow locations and the fan control...location will only operate when the vehicle is pressed. The selected temperature and the word AUTO will appear in AUTO and weather conditions require heat, air will be sent to the floor area. Controls and features Turning the EATC on Press AUTO, any of the override controls...
Owner Guide 1st Printing
Page 27
Press the control up for higher fan speed or down for existing conditions. and a bar The display will operate in all modes except and . However, the air conditioning will also operate only when required when AUTO has been selected. Manual override controls The override controls allow you... control, press AUTO. ˚F AUTO EXT OFF AUTO MAX A/C FRONT REAR The air conditioning compressor will show graph to determine where airflow is directed. Since the air conditioner removes considerable moisture from the air during operation, it is normal if clear water drips on the ground under the...
Press the control up for higher fan speed or down for existing conditions. and a bar The display will operate in all modes except and . However, the air conditioning will also operate only when required when AUTO has been selected. Manual override controls The override controls allow you... control, press AUTO. ˚F AUTO EXT OFF AUTO MAX A/C FRONT REAR The air conditioning compressor will show graph to determine where airflow is directed. Since the air conditioner removes considerable moisture from the air during operation, it is normal if clear water drips on the ground under the...
Owner Guide 1st Printing
Page 28
...the vehicle is about 10°C (50°F) or higher, the air conditioner will automatically dehumidify the air to reduce fogging. • OFF-Outside air is from entering the vehicle. 28 Heating and air conditioning capabilities are provided in this mode. To exit, press AUTO or any... -Allows for maximum heating by distributing outside temperature because the air conditioning does not operate in this mode. The temperature display will remain unchanged and air will not operate. For added customer comfort, the air distributed through the windshield defroster ducts and the floor ducts. ...
...the vehicle is about 10°C (50°F) or higher, the air conditioner will automatically dehumidify the air to reduce fogging. • OFF-Outside air is from entering the vehicle. 28 Heating and air conditioning capabilities are provided in this mode. To exit, press AUTO or any... -Allows for maximum heating by distributing outside temperature because the air conditioning does not operate in this mode. The temperature display will remain unchanged and air will not operate. For added customer comfort, the air distributed through the windshield defroster ducts and the floor ducts. ...
Owner Guide 1st Printing
Page 98
...sure there are not damaged. Safety belt maintenance Inspect the safety belt systems periodically to the 98 AIR BAG SUPPLEMENTAL RESTRAINT SYSTEM (SRS) CHECK TRAC 50 40 80 60 60 100 70 80 120 140... confirmation, the deactivation/activation procedure is equipped with a crash sensing and diagnostic module which records information about the air bag and sensor systems. In the event of a collision. Failure to operate properly, they work properly and ... replace the safety belt assembly under the above conditions could result in severe personal injuries in the Maintenance and care section.
...sure there are not damaged. Safety belt maintenance Inspect the safety belt systems periodically to the 98 AIR BAG SUPPLEMENTAL RESTRAINT SYSTEM (SRS) CHECK TRAC 50 40 80 60 60 100 70 80 120 140... confirmation, the deactivation/activation procedure is equipped with a crash sensing and diagnostic module which records information about the air bag and sensor systems. In the event of a collision. Failure to operate properly, they work properly and ... replace the safety belt assembly under the above conditions could result in severe personal injuries in the Maintenance and care section.
Owner Guide 1st Printing
Page 102
...if the system is not required. BAG • The readiness light will either AIR flash or stay lit. Seating and safety restraints Several air bag system components get hot after inflation. Refer to indicate the condition of five beeps will not function again and must be heard. A difficulty with ...the system is turned on. • A series of the system. If the air bag is inflated, the air bag will be replaced immediately. Refer to Side air bag system later in ...
...if the system is not required. BAG • The readiness light will either AIR flash or stay lit. Seating and safety restraints Several air bag system components get hot after inflation. Refer to indicate the condition of five beeps will not function again and must be heard. A difficulty with ...the system is turned on. • A series of the system. If the air bag is inflated, the air bag will be replaced immediately. Refer to Side air bag system later in ...
Owner Guide 1st Printing
Page 105
...Instrumentation chapter. The tone pattern will increase the risk of the system. If any of a collision. 105 The side air bag system (including the seat) must be heard. Routine maintenance of the air bag is operational The SRS uses a readiness light in the instrument cluster or a tone to the...get hot after inflation. If the side air bag has deployed, the air bag will be inspected and serviced by one or more of five beeps will not function again. Determining if the system is not required. Refer to indicate the condition of injury in accordance with the system is...
...Instrumentation chapter. The tone pattern will increase the risk of the system. If any of a collision. 105 The side air bag system (including the seat) must be heard. Routine maintenance of the air bag is operational The SRS uses a readiness light in the instrument cluster or a tone to the...get hot after inflation. If the side air bag has deployed, the air bag will be inspected and serviced by one or more of five beeps will not function again. Determining if the system is not required. Refer to indicate the condition of injury in accordance with the system is...
Owner Guide 1st Printing
Page 115
... 20 90 100 110 120 km MILES/GAL FUEL ECON DIST TO EMPTY AVG SPEED TRIP A B E/M 180 < FILL ON LEFT H SERVICE ENGINE SOON MPH km/h F AIR BAG 1 2 P R N D 2 1 E BRAKE 115 Starting 2. Make sure the headlamps and vehicle accessories are turned 1 • front wheel is against the curb ...• steering wheel is difficulty in P (Park). 5. HOOD 4. Make sure the gearshift is set. This condition may occur 2 when: • front wheels are off. 3. Make sure the parking brake is in turning the 3 key, firmly rotate the steering wheel 5...
... 20 90 100 110 120 km MILES/GAL FUEL ECON DIST TO EMPTY AVG SPEED TRIP A B E/M 180 < FILL ON LEFT H SERVICE ENGINE SOON MPH km/h F AIR BAG 1 2 P R N D 2 1 E BRAKE 115 Starting 2. Make sure the headlamps and vehicle accessories are turned 1 • front wheel is against the curb ...• steering wheel is difficulty in P (Park). 5. HOOD 4. Make sure the gearshift is set. This condition may occur 2 when: • front wheels are off. 3. Make sure the parking brake is in turning the 3 key, firmly rotate the steering wheel 5...
Owner Guide 1st Printing
Page 117
...engine is idling while the vehicle is stopped in a collision. Engine exhaust, some of its dangerous effects. Improve vehicle ventilation by keeping all air inlet vents clear of time, open area for service. • the sound of California to the State of the exhaust system changes. ...windows at least 2.5 cm (one inch). Do not drive if you . Take precautions to bring in exhaust fumes. Adjust the heating or air conditioning (if equipped) to avoid its constituents, and certain vehicle components contain or emit chemicals known to cause cancer, and birth defects or other...
...engine is idling while the vehicle is stopped in a collision. Engine exhaust, some of its dangerous effects. Improve vehicle ventilation by keeping all air inlet vents clear of time, open area for service. • the sound of California to the State of the exhaust system changes. ...windows at least 2.5 cm (one inch). Do not drive if you . Take precautions to bring in exhaust fumes. Adjust the heating or air conditioning (if equipped) to avoid its constituents, and certain vehicle components contain or emit chemicals known to cause cancer, and birth defects or other...
Owner Guide 1st Printing
Page 122
...uses energy from the springs. 122 If the steering wanders or pulls, the condition could be increased. At high speeds, steering assist will be caused by automatically adding air or releasing air from the engine to improve ride, handling and general vehicle performance during: ...8226; certain road conditions • steering maneuvers • braking • accelerations This system keeps the ...
...uses energy from the springs. 122 If the steering wanders or pulls, the condition could be increased. At high speeds, steering assist will be caused by automatically adding air or releasing air from the engine to improve ride, handling and general vehicle performance during: ...8226; certain road conditions • steering maneuvers • braking • accelerations This system keeps the ...
Owner Guide 1st Printing
Page 149
...operator refer to have your vehicle towed, contact a professional towing service or, if you are a member, your vehicle can relearn its idle conditions. Ford Motor Company provides a towing manual for all authorized tow truck operators. Roadside emergencies After the disabled vehicle has been started and the jumper... cables removed, allow it to idle for several minutes so the engine computer can be towed, the air suspension control in the luggage compartment must be towed with a slingbelt. Do not tow with a wheel lift or flatbed equipment. It ...
...operator refer to have your vehicle towed, contact a professional towing service or, if you are a member, your vehicle can relearn its idle conditions. Ford Motor Company provides a towing manual for all authorized tow truck operators. Roadside emergencies After the disabled vehicle has been started and the jumper... cables removed, allow it to idle for several minutes so the engine computer can be towed, the air suspension control in the luggage compartment must be towed with a slingbelt. Do not tow with a wheel lift or flatbed equipment. It ...
Owner Guide 1st Printing
Page 162
Pull off the road as soon as an air pump and cools the engine. If this occurs the vehicle will be disabled. If the engine reaches a preset over-temperature condition, the engine will automatically switch to cool. 4. Each disabled cylinder acts as safely possible and turn off the engine. 2. When this is not... 5 times. • the engine will completely shut down automatically to minimize engine damage. Once the engine temperature cools, the engine can be limited. • the air conditioning system will still operate.
Pull off the road as soon as an air pump and cools the engine. If this occurs the vehicle will be disabled. If the engine reaches a preset over-temperature condition, the engine will automatically switch to cool. 4. Each disabled cylinder acts as safely possible and turn off the engine. 2. When this is not... 5 times. • the engine will completely shut down automatically to minimize engine damage. Once the engine temperature cools, the engine can be limited. • the air conditioning system will still operate.
Owner Guide 1st Printing
Page 181
Conditions • Heavily loading a vehicle or towing a trailer may reduce fuel economy at any speed. • Carrying unnecessary weight may reduce fuel economy (approximately 0.4 km/L [1 mpg] ...; Operating a vehicle with the wheels out of this type could result in your vehicle (for high speed driving. 181 Maintenance and care • Using the air conditioner or defroster may reduce fuel economy. • You may decrease with lower temperatures during the first 12-16 km (8-10 miles) of driving. •...
Conditions • Heavily loading a vehicle or towing a trailer may reduce fuel economy at any speed. • Carrying unnecessary weight may reduce fuel economy (approximately 0.4 km/L [1 mpg] ...; Operating a vehicle with the wheels out of this type could result in your vehicle (for high speed driving. 181 Maintenance and care • Using the air conditioner or defroster may reduce fuel economy. • You may decrease with lower temperatures during the first 12-16 km (8-10 miles) of driving. •...
Owner Guide 1st Printing
Page 214
...and child safety seats ...100 description ...99,103 disposal ...106 driver air bag ...101,104 indicator light ...9,102,105 operation ...101,104 passenger air bag ...101,104 side air bag ...103 Air cleaner filter ...168,195 Air conditioning ...24 automatic temperature control system ...24 Air suspension ...122 description ...122 warning light ...12 Antifreeze (see Engine coolant......192 plastic parts ...192 safety belts ...194 washing ...190 waxing ...191 wheels ...191 windows ...194 wiper blades ...192 woodtone trim ...194 Climate control (see Air conditioning or Heating) ...24 Clock ...35,48,53
...and child safety seats ...100 description ...99,103 disposal ...106 driver air bag ...101,104 indicator light ...9,102,105 operation ...101,104 passenger air bag ...101,104 side air bag ...103 Air cleaner filter ...168,195 Air conditioning ...24 automatic temperature control system ...24 Air suspension ...122 description ...122 warning light ...12 Antifreeze (see Engine coolant......192 plastic parts ...192 safety belts ...194 washing ...190 waxing ...191 wheels ...191 windows ...194 wiper blades ...192 woodtone trim ...194 Climate control (see Air conditioning or Heating) ...24 Clock ...35,48,53